- The problem
- Hyundai Motor America (Hyundai) is recalling certain 2018-2020 Genesis G80, 2017-2022 G90, and 2019-2022 G70 vehicles equipped with a 3.3-liter V6 turbocharged engine. The left turbocharger oil feed pipe may deteriorate and leak oil.
- The risk
- An oil leak in the presence of hot engine components can increase the risk of an engine compartment fire.
- The fix
- Dealers will replace the left turbocharger oil feed pipe, free of charge. Owner notification letters were mailed May 3, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 019G. This recall expands and replaces recall number 19V-538. Vehicles previously repaired under 19V-538 will need to have the new remedy completed.
Engine & cooling
2017 Genesis G90 Engine problems
Owners have filed 9 complaints about the 2017 Genesis G90's engine & cooling with NHTSA - 33% of all its complaints, most recently on September 22, 2026. Stalling, loss of power, oil consumption, overheating, head gaskets, timing chains and engine failure.
- Complaints
- 9
- Recalls
- 2
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
Engine recalls for the 2017 Genesis G90
- The problem
- Hyundai Motor America (Hyundai) is recalling certain 2018 Genesis G80 and 2017-2018 Genesis G90 vehicles equipped with 3.3 liter turbocharged engines. The turbocharger oil supply pipe may have a loose seal, causing oil to leak onto the exhaust manifold.
- The risk
- Oil leaking onto the exhaust manifold increases the risk of a fire.
- The fix
- Hyundai will notify owners, and dealers will replace the turbocharger oil supply pipe, free of charge. The recall began October 3, 2019. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 003G.
Engine complaints
The contact owns a 2017 Genesis G90. The contact stated that while the vehicle was stationary, the contact became aware of smoke coming from the driver's side of the engine. While stopped at a red light, the vehicle was smoking with an oil-burning odor. Additionally, the contact stated that the air bag module light was illuminated. The manufacturer was notified of the failure. The contact referenced NHTSA Campaign Number: 24V107000 (Electrical System) and 24V191000 (Engine and Engine Cooling) as possible causes for the failure. The dealer and the manufacturer agreed to assist with the recall repairs but had not provided the parts for the repairs. The failure mileage was 118,000.
See attached document for complaint.
* Recall Campaign Number : [018G, 019G] I. Statement of Complaint This complaint concerns a failure in a critical safety-related component that was previously addressed under a mandatory manufacturer recall, and the subsequent refusal by the authorized dealership to provide a second no-charge repair for the same repeated failure. II. Chronology of Events * Original Recall Repair: Approximately thirteen (13) months ago, 8/30/2024 the vehicle was taken to Anaheim Hyundai to address a safety recall concerning the...
Read the full complaint
oil feed pipe. The prescribed remedy, a replacement of the oil feed pipe, was completed at no cost under the recall campaign. * Second Failure (Current Event): On or about 10/6/2025, while the vehicle's engine was running, I observed smoke rising from the engine compartment. The vehicle was immediately taken to a local independent mechanic who diagnosed the issue as a burst oil feed pipe - the identical component subject to the prior recall. * Attempted Repair at Anaheim Hyundai (Denial): The vehicle was then towed back to Anaheim Hyundai. The service department acknowledged that the component failure was the same issue addressed in the previous recall. However, the dealership has now refused to perform the repair under the recall process, citing a specific 12-month policy set by Hyundai Motor America regarding the warranty on recall remedies, which has now expired. III. Request for Intervention The failure of the previously installed recall remedy (the oil feed pipe) exposes the vehicle to the original safety risk, including potential engine failure and fire hazards, and the manufacturer's refusal to re-remedy the defect effectively negates the purpose of the mandatory recall. I request that NHTSA investigate this matter and compel Hyundai Motor America to: * Honor the original safety recall and provide a permanent, effective remedy at no charge to the consumer. * Clarify the consumer's right regarding the warranty on recall remedies, fails after install
The contact owns a 2017 Genesis G90. The contact stated that while driving at 50 MPH, the check engine warning light illuminated. The driver immediately pulled over. The vehicle was towed to the local dealer, where it was diagnosed, and it was determined that four crankshaft position sensors and the valve cover gasket needed to be replaced. The vehicle was repaired, but the failure recurred. The contact called the local dealer and was informed that the failure might be related to the timing chain. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.
The check engine light keeps coming on. We had spark plugs changed and still keeps miss firing. We are unable to switch between drive modes smoothly. We have taken in for service numerous times.
See attached document for complaint.
The contact owns a 2017 Genesis G90. The contact stated that while the vehicle was parked and running, the vehicle was idling rough and shaking. The vehicle restarted; however, the shaking failure recurred. The vehicle was not repaired. The contact received notification of NHTSA Campaign Numbers: 24V107000 (Electrical System) and 24V191000 (Engine and Engine Cooling) however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.
The contact owns a 2017 Genesis G90. The contact stated that while driving at an undisclosed speed, there was smoke coming from underneath the hood. The oil warning light intermittently illuminated. The vehicle was taken to an independent mechanic, who determined that the engine was leaking oil and advised the contact to take the vehicle to the dealer. The vehicle was then taken to the dealer, where it was diagnosed that there was oil leaking from the turbo chargers and the engine block. The contact was not aware of what needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 82,000.
I have replaced my thermostat four times in the last 18 months and I had it towed to the dealership again this morning for the same overheating problems.
Genesis G90 engine complaints by year
G90 engine problems, every yearSource: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data