General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module...
Electrical system
GMC Envoy Electrical problems by year
766 complaints filed with NHTSA about the GMC Envoy's electrical system. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.
Electrical complaints by model year
Electrical recalls
General Motors (GM) is recalling certain model year 2006 Chevrolet Trailblazer EXT and GMC Envoy XL and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier, SAAB 9-7x, and Isuzu Ascender vehicles, originally sold or currently registered in Connecticut...
Certain sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standards no. 101, "Control location, identification, and illumination" and no. 208, "Occupant crash protection." These vehicles have an intermittent...
Latest Envoy electrical complaints
My switch on drivers door started on fire right after I purchased vehicle from third party. There was no warning I just smelled smoke while driving and pulled it out
The contact owns a 2003 GMC Envoy. The contact stated that while in drive(D), the vehicle shut off and then restarted. The message "Service Engine Soon" was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the instrument cluster needed to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer who installed the original instrument cluster, but the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 98,000.
1) I just purchased the vehicle in Oct 2026 & 3 days after purchase, it broke down in Walmart parking lot due to, all the antifreeze pouring out. 2) December 2026 had to replace the front tires as they were stripped to the threads from rubbing against the fender wells. 3) January 2026 Wouldn't start, wouldn't turn over or anything. Had the ignition replaced. Ran fine for one week. 4) Currently won't start. Broke down.
I was living in my car and the windows and door lock cluster caught on fire I had to tear my door panel off to get to the source and unplug it I believe there is a major electrical issue with this vehicle I shouldn't be driving it also my heater fan stopped working on 4 and 5 works on 1 2 and 3 but not 4 or 5 please help me get this recalled so I can finally get this vehicle fixed right this is so dangerous I could have burnt up in my car 7
The contact owns a 2004 GMC Envoy. The contact stated that while the vehicle was parked and unoccupied, the contact noticed that the front passenger's door was on fire. The contact stated that he arrived home just in time and noticed the fire. The contact stated that, because it was raining, the contact's wife had powered the window up; however, the contact noticed that the window was down when the fire occurred. In addition, the contact stated that the fire was blazing, and after the fire was extinguished, the...
Read the full complaint
smoke was still visible. The contact extinguished the fire. The contact disconnected the battery. In addition, the contact stated that it could have been a huge fire because the fuel tank had just been refilled prior to the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 133,295.
The car's gas gauge and fuel range indicator are problematic. The fuel gauge quickly drops from a higher reading, like 3/4 full, to empty. After this, the gauge and the fuel range both fluctuate while driving, making it impossible to determine the fuel level.
On steering wheel where the GMC logo is . Melted/Melting from underneath. Some type of clear color gooey. Have been told it is seal for airbag. Also none of the chimes are not working at all example * seat belts, door,blinkers,dashboard chimes *dummy lights*,along with Bose stereo. Last issues are REAR VIEW MIRROR... KEEPS FALLING OFF. have taken to dealership SEVERAL TIMES! Now they are saying that I need to contact my auto insurance provider to put in claims.
The contact owns a 2007 GMC Envoy. The contact stated that the power switch used to adjust the front driver seat had failed to operate as needed. The contact stated that the power switch had been replaced a total of three times within a two-month time frame. Recently, the power switch had failed for a fourth time and as the contact went to replace the fuse, the fuse box was so hot that it burned the contact's right hand and left a blister. The contact did not seek any medical attention for the injury. Upon...
Read the full complaint
investigation, the contact discovered NHTSA Campaign Number: 12V406000 (Electrical System, Visibility) which was linked to the failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.
The driver side window control caught fire, while the vehicle was sitting overnight. It was sitting by itself without reason to catch fire, but it did burn inside the driver side door.
Unknown All the cluster panels quite working. RPM, Speed, Oil, Water, Gas shows always empty. Danger because have to guess my speed and never know if I have enough gas, oil, or water in my car. Also sometimes when I shut off my car I cannot get the key out of the steering column. Cannot leave my car without my keys.
The contact owned a 2005 GMC Envoy. The contact stated while driving approximately 60 MPH the entire dashboard illuminated and needles on gauges had begun to move independently. The contact heard an abnormal "popping" sound from the front end of the vehicle and gray smoke was emitted from under the hood, the vehicle stalled. The contact was able to pull off of the roadway and placed the vehicle into park (P) with difficulty. The contact exited the vehicle and moved away towards the rear end. The contact stated that...
Read the full complaint
she noticed flames under the vehicle located at the front end. The contact stated that within 3 minutes of observing the flames under the vehicle, the entire front end became engulfed by flames. The police and fire department arrived on the scene. The contact stated that the fire department used a chemical to extinguish the flames, the contact stated that the flames had burned not only the front end and front tires but the front part of the passenger cabin including the seats. The contact stated that the highway patrol wrote a report and had been informed by the fire department that the fire appeared to have been caused by the electrical system. The vehicle was towed to an impound lot. The manufacturer had not been informed of the failure. The failure mileage was unknown.
The contact owns a 2003 GMC Envoy. The contact stated that the headlights ceased to operate as needed. Upon taking the vehicle to a local Pep Boys, it was diagnosed that the electrical wiring harness was burned and needed to be replaced. Additionally, the bulbs needed to be replaced. The contact stated that the vehicle was repaired; however, the failure recurred. The vehicle was taken back the local Pep Boys, who replaced the electrical wiring harness and the bulbs a second time; however, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
Headlight's,taillight's,turn signals stop working whenever they want.It's pretty scary to lose your headlight's when your driving at night.There's nothing i can do about it,except to sit wherever it happend and wait for them to come back on.My wife was following me one day and told me my brakelight's and turn signal stopped working and started to work again,she said this happened a couple time's at the same red light.There a couple of thing's (electrical)inside the vehicle that don't work anymore but i really dont...
Read the full complaint
care about them.To get the odometer to work i have to knock pretty hard on the plastic cover that cover's the instrument cluster,sometimes it stay's on,most of the time it wont stay on.The DIC (driver control center) doesn't work anymore.I cant even get to it.The speakers on the left side of the vehicle dont work anymore.I thought i would tell you about the inside also because it could be part of the problem.All of this happened when i was driving home from my daughter's two night's ago.I bought this vehicle about three or four's year's ago,and i had no problem's with it untill the other night.The person i bought it from is a good friend of mine.He said he never had a problem with it,plus i have been in this vehicle countless times,that's why i bought it. Thank you.
I purchased my vehicle in oct of 2021 in Nov 2021 is when my car started failing my car started to lose power also started smoking from the lower passenger side no warning lights came on besides the oil warning light since Nov 2021 my car has been losing power it only goes up to about 40 m.p.h I have been smelling fuel coming from some where my tail and license plate light and back driver side inside car light stopped working the engine light turns on and off the steering wheel makes the car lose a little bit of...
Read the full complaint
power when I turn the wheel or when I roll up and down the windows or adjust my seat my ac does not work the back ac turns on by it's self to the heater does not work when I have it turned all the way to the 5 I hear clicking knocking noises in the back passenger side of the car my fuel injectors had puddles of oil in them the car gets really hot and blows hot air the engine is always hot the seatbelt lights are constantly flashing my check engine light as of today flashes on and off and the car jumps also my car caught on fire under the hood where the O2 sensor is started smoking than caught on fire.
Went to drive home at night lights were working then all the sudden went out. Pulled over checked fuses n restarted auto and still no lights, the dash board lights were out as well. Safety of other drivers and my family were affected. Did have to have a friend come and get us. And went to get auto next day n still no lights. When got home checked everything agine and fuses were ok the wireing look all intact. Still no lights. Or dash lights.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data