2015 Kia Optima Engine problems

I was driving to work when all of the sudden I was pressing my gas, but I wasn't accelerating. I noticed my brakes and steering wheel were hard to push and turn. My car stopped in the middle of the road. I turned off my car and tried to turn the ignition and all I got was a single click. My engine, battery and oil lights were now on. They were not before. After 25 minutes in the middle of the road a sheriff came and pushed me to the side. When I put my car in neutral it was hard to steer and my brakes were hard to...

There is a known issue with this vehicle and the fix by KIA is not safe nor fair to the consumer. Kia's knock sensor recall centers on the Knock Sensor Detection System (KSDS) software update for Theta II GDI engines. The update listens for rod bearing wear, triggers a check engine light and limp mode via Code P1326, and extends the engine warranty up to a lifetime or 15 years/150,000 miles. My problem is that we had to car in on May of 2026 after in went into limp mode. They updated the software. The car again...

My energy in my car started messing up with only 150,000 miles it had a long knocking sound and it would not got over 20 miles while driving

My 2015 KIA optima experienced a catastrophic engine fire while I was driving. There was no warning, I just heard a boom in the engine bay the breaks stopped working and all electrical cut out. As I'm coasting, because I'm unable to stop, flames started to come in through under the dash. I couldn't turn the car off, nor put it in park so the doors stayed locked. The driver window was opened just enough for me to grab the top and break it, allowing me to crawl out. The car coasted itself to the shoulder then blew up (I had a full tank of gas.). All this happened in the manner of 30 to 35 seconds. It's important to note that KIA just replaced the engine 2 months prior to this incident.

The contact owns a 2015 Kia Optima. The contact stated that for over 8 years, the vehicle was experiencing excessive oil consumption. There was no warning light illuminated. The contact became aware that there was an oil leak on the ground underneath the vehicle. The vehicle was taken to the dealer on several occasions for the oil consumption failure; however, the dealer was unable to find a fault with the vehicle. The dealer had not yet provided a cause for the oil leak. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,000.

The engine in my vehicle failed while putting the car into reverse to back into my garage. I thank God I wasn't on the road when this happened. I took the car into a mechanic who confirmed that the engine was locked and that the car was very low on oil(even though I had my oil changed by him a few months prior). There was an undetected oil leak that led to the engine failure. The warning indicators didn't appear on my dash until after my engine failed.

This is a formal vehicle safety complaint regarding a manufacturer's active refusal to remedy a known safety defect under an active recall campaign guidelines.My 2015 Kia Optima Turbo experienced an active internal mechanical engine knock, violent sputtering, and a complete engine seizure. The vehicle is currently sitting un-driveable at an authorized Kia dealership.The required Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the incident, legally qualifying...

The contact owns a 2015 Kia Optima. The contact stated that while driving at an undisclosed speed, the vehicle stalled. During the failure, several unknown warning lights flashed on the instrument panel and there was smoke coming from under the hood of the vehicle. The contact exited the vehicle, and there were flames coming from underneath the hood. The Fire Department was called to the scene and extinguished the flames. During the failure, the vehicle was destroyed. A Police report was filed, and the vehicle was...

My girlfriend was driving on interstate 95 to pick me up from the metro. The engine suddenly cut off in a manner that appears to have melted the wiring harness of the vehicle, risking fire. She was able to safely get to the side of the road and call a tow. After taking it to a local repair shop, they diagnosed the issue as related to the KSDS recall. We had it towed to the dealership that has also confirmed it is related to the recall. The engine is completely seized following this incident and it's worth noting that Kia is completely denying the engine repair claim as the KSDS update was not installed prior.

The contact owned a 2015 Kia Optima. The contact stated that while driving to the residence, the vehicle caught on fire. The contact stated that while at a traffic light, the vehicle suddenly shut off. After exiting the vehicle, the hood was opened, and there was smoke coming from the engine compartment. The contact called an independent mechanic and, within two minutes, became aware of the fire. The contact called 911 for the Emergency Services. The Fire Department arrived and extinguished the fire. There was no...

While driving my 2015 Kia Optima, the engine failed completely without warning. The vehicle lost power while in motion approximately 300 miles away from my home. All warning lights illuminated and the car shut down during driving conditions, creating a serious safety hazard. The vehicle was towed to a Kia dealership where it was inspected. I was informed the engine has failed and may be related to the known 2.4L engine defect and prior recall campaign involving this engine type. This vehicle has a history of...

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The primary failure involved the engine. The vehicle experienced a major engine failure that resulted in an engine replacement under a manufacturer recall. After the replacement engine was installed, the vehicle later developed additional engine-related problems. An independent mechanic advised that the vehicle would require another engine replacement or extensive engine repairs. Additional defects included a...

P1326 code flashing engine light knock sensor went out 3 times in 6 months and just replaced it again and this time engine light didn't go off I was reading that there was a recall on this but apparently mine doesn't state it. Car cannot pass emissions if engine light is on and the 15th of June is approaching. The car doesn't make any sounds or nothing.

The contact owns a 2015 Kia Optima. The contact received notification of NHTSA Campaign Number: 21V331000 (Service Brakes, Hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was take to O'Reilly's to be diagnosed. The DTC: P1326; was retrieved. The contact attempted to start the...

The contact owns a 2015 Kia Optima. The contact stated that while accelerating at 55 MPH, there was an abnormal burning smell detected. While driving, she was alerted by another driver who informed her that the vehicle was on fire. The passengers were able to exit the vehicle safely. The vehicle was engulfed in flames. There were no reported injuries. The vehicle was towed to a tow lot. The vehicle was previously taken to an independent mechanic, who said the engine was bad. The engine was previously replaced at...

The contact owned a 2015 Kia Optima. The contact stated that while driving at 65 mph and slowing down to enter a parking garage, she observed black smoke emanating from under the hood, and the vehicle stalled. The contact then observed flames near the windshield wipers coming from under the hood of the vehicle. The contact exited the vehicle and called 911. She observed flames coming from under the hood and under the vehicle, and the vehicle became engulfed in flames. The contact stated that the garage manager...

Was driving down the interstate and the engine lost some power and the engine blew and parts of the connecting rod was on the outside of motor which blew a hole in the block and oil went into the intake manifold and pieces of the piston ring was in there and engine shut off, and seen that this has been a problem with these cars

Engine seized while driving.

Was driving then suddenly the engine shut off I was able to pull to the side Tried to restart it I saw smoke coming out from the hood I did tow it to my apartment looks like the engine is locked I contacted kia they said I have a branded title they can't do anything about it Even if the car title was branded to a rear ending collision And the engine had oil in it

The contact owned a 2015 Kia Optima. The contact stated that while driving at 60 MPH, during a DoorDash delivery, the vehicle vibrated. The contact pulled to the side of the road and noticed smoke emitting underneath the vehicle from the right side. The contact exited the vehicle and noticed smoke emitting from underneath the hood. The state troopers were called. By the time the fire department arrived, the vehicle was engulfed in flames, and the engine had exploded. The fire department extinguished the fire. The...

The contact owns a 2015 Kia Optima. The contact stated that while driving at 40 MPH, there was smoke coming from underneath the hood, and the engine overheated. The check engine warning light was illuminated. The contact was able to pull over to the side of the road and add coolant to the coolant reservoir. The vehicle slowly started and was driven to the destination. The contact stated that the engine was overheating if driven for more than 10 minutes. The vehicle was taken to an independent mechanic, where it was...

On Friday, February 27, 2026. This vehicle is being driven and vehicle seized and disabled on the road. In the middle of rush hour, traffic in a dangerous spot, local police had to be called out to assist, as no location was identified for a tow truck to be able to pick it up... The police had to dispatch their own tow service. After being towed from location where a car was disabled, mechanic looked at vehicle identifying there was no oil in the car. However on, September 9, 2025 an oil change was performed on the...

The vehicle started making a loud knocking/tapping noise while driving. The vehicle has randomly acted as if it was going to stall while driving prior to the knocking. Instantly the car was brought home and parked. A mechanic has assessed the vehicle and states the noise we are hearing is the rods. We also contacted another mechanic and they advised us to look up the VIN due to a recall for 2015 Kia optima's and the failure of this exact issue but we learned it was only for hybrid models even though this model...

Engine seized and won't turn at all

Engine failure while driving on freeway. Almost hit by semi truck. Towed to Dealership. Engine check light flashing complete loss of power. Kia refusing engine replacement under settlement.