2019 Lincoln MKC Engine problems

After my check engine light came on the dealership performed a cooling system pressure test and borescope inspection which confirmed a cylinder 2 misfire caused by structural coolant intrusion into the engine block. The dealership repair estimate is over $14,000. As an elderly and handicapped individual facing unstable housing, this catastrophic vehicle failure leaves me stranded, and the out-of-pocket cost is a severe and impossible financial hardship. •Known Inherent Defect: I learned that this exact...

See attached document for complaint

There is a coolant leak going into the cylinder 3 causing misfire and overheating and engine shutoff Car shut down and locked up on the highway and I had to coast to the shoulder and get it towed. The ford dealer said it needs an engine replacement specifically a long block assembly estimated at 10k. It was inspected by the ford dealership. there was a code p0303 saying misfire so I got all the spark plugs replaced and when i was driving home from work the car locked up and said overheating and had to coast off...

I am filing an urgent safety complaint regarding a severe Ford/Lincoln EcoBoost engine defect, fraudulent recall reporting, and the illegal refusal of repair on my vehicle, which has only around 20,000 miles. Since this vehicle is under an active safety recall, the manufacturer and dealership have a strict legal obligation to perform the recall repair at no cost to the consumer.My vehicle recently experienced a major engine failure with the Check Engine Light illuminated The authorized dealership diagnosed the...

Sept 2026. Coolant intrusion. Causes engine light to illuminate, engine to overheat, rendering vehicle unable/unsafe to drive, potential fire risk. The failure was diagnosed by Lincoln dealer as a known defect via technical service bulletin. My research revealed this defect is found in numerous Ford vehicles.

The contact owns a 2019 Lincoln MKC. The contact stated that upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic and was diagnosed with coolant intrusion in cylinder #3 and head gasket failure. The contact was informed that the engine and turbo charger needed to be replaced. The manufacturer, Lincoln, was notified of the failure, but no assistance was provided. The failure mileage was 55,304.

Coolant intrusion into the engine at 20000miles. complete engine failure. lincoln dealership diagnosed that a long-block engine replacement is required. serious safety hazard due to potential sudden stalling while driving.

The contact owns a 2019 Lincoln MKC. The contact stated that while starting the vehicle, the vehicle unexpectedly jolted. The contact stated that while driving 30 MPH, the check engine warning light illuminated. The vehicle was taken to the dealer to be diagnosed, and it was determined that coolant was leaking into the engine block, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 76,131.

Coolant intrusion into the cylinder and requires a replacement of the long block engine assembly which was a known issue by Ford/Lincoln with no recalls issued. The problem has been confirmed by authorized Ford/Lincoln dealer and independent service center. Warning lights illuminated when car was brought to dealer for inspection. It poses significant safety risk that actively endanger me and passengers while driving due to sudden loss of power, engine stalling, engine fire, loss of braking and steering assistance.

The contact owns a 2019 Lincoln MKC. The contact stated that the check engine warning light illuminated, and the message "Service Soon" was displayed on the app, and the failure was caused by a misfire. The vehicle was taken to the dealer to be diagnosed, and it was determined that there was coolant intrusion into the engine cylinders, which caused the engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that new spark plugs were previously...

The vehicle needs a complete engine replacement due to a coolant intrusion issue. The safety of myself and my family are of my utmost concern. Overheating of the system can cause sudden engine stalling, catastrophic power loss at highway speeds, a risk of collision, and toxic vapor exposure inside the vehicle. Furthermore, A leaking heater core vents sweet-smelling but toxic antifreeze vapors into the passenger compartment and prolonged breathing of heated glycol fumes can trigger dizziness, headaches, and nausea...

To NHTSA: I am filing this complaint about a dangerous stall/overheat defect in my 2019 Lincoln MKC, VIN [[redacted]], currently at 79,820 miles. This vehicle was built 2018-10, before Ford's engine redesign, and it is now undrivable due to coolant intrusion into the engine, a known and documented defect covered under Ford TSB 22-2229 for the 2.0L EcoBoost engine. What happened: the car overheated on me at Church's Chicken. I came out with coolant to top it off, and cautiously drove it to Dr Underhood Repair...

1. What component or system failed or malfunctioned, and is it available for inspection upon request? Answer: Engine / Powertrain (Engine Block & Cooling System). The vehicle suffered an internal engine failure caused by coolant intrusion into Cylinder #4, requiring a full engine long block replacement per Ford Technical Service Bulletin (TSB) 22-2229. The vehicle and component are available for inspection upon request. 2. How was your safety or the safety of others put at risk? Answer: The engine suffered a...

Car started shaking roughly when started, check engine light came on for cylinder misfire. Known engine problem where coolant leaks in to the engine block due to a known defect from Ford for these 2.0L engines. There is a TSB 22-2229 ([[redacted]]) already issued for this. Dealer inspected and confirmed the problem. Now the entire engine long block needs to be replaced resulting in $10,000 repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Component: Engine (2.0L EcoBoost) - coolant intrusion into cylinders What failed: The engine in my 2019 Lincoln MKC (2.0L EcoBoost, approximately 83,000 miles) failed due to internal coolant intrusion into the cylinders. This is a known defect in this engine, documented by the manufacturer in TSB 22-2229 (superseding TSB 19-2346), which acknowledges coolant leaking into the cylinders on 2.0L EcoBoost vehicles and specifies complete long block engine replacement as the only repair. My vehicle and the failed engine...

There is coolant intrusion into the cyl. It is a known concern and many complaints on line. Lincoln refuses to assist in the engine repair or replacement. Going down the road the engine misses and looses power causing difficulty controlling vehicle causing unsafe conditions for all traffic.

The engine on my 2019 Lincoln MKC has failed due to coolant intrusion. A known issue with this model car between 2017-2019. There are two cracked cylinders on the engine block. The dealership says that the engine must be replaced.

Engine has coolant intrusion at 57,000 miles. Mechanic recommends full engine replacement.

The contact owns a 2019 Lincoln MKC. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the following day, while attempting to start the vehicle, the contact noticed white smoke coming from the exhaust. The contact stated that while driving at an undisclosed speed, the vehicle idled and drove unusually rough. In addition, the contact stated that the vehicle misfired. The vehicle was taken to the dealer where it was diagnosed with a failed...

The contact owns a 2019 Lincoln MKC. The contact stated that the engine experienced rough idling after starting with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who replaced the spark plugs and coil pack; however, the failure recurred with the vehicle shuddering while driving. The vehicle was taken to the dealer, who determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 58,000.

Engine failure TSB 19-2346, A known/common issue with this engine. The car only has 73,790 miles on it. The car started shaking when started, engine light on, empty coolant reservoir and off then parking brake came on randomly several times , and the brakes locked up twice, which resulted in going over a curb. Discontinued driving the vehicle after that incident obviously due to safety. Ford service center gave a $13,000 repair estimate. The vehicle is still at Ford and available for inspection.

The engine on my 2019 Lincoln MKC (2.0L EcoBoost) suffered a sudden internal failure without warning shortly after the factory powertrain warranty expired. The vehicle had no prior drivability issues, no warning lights, and had been maintained on schedule. While driving, the engine began running roughly and quickly lost power. The vehicle became unsafe to operate and had to be towed. The dealership diagnosed the engine as having internal mechanical failure requiring complete engine replacement. I was told the...

The head gasket has failed, leading to coolant intrusion into the number 2 cylinder. Several misfires occurred due to this. This is a known issue due to the design of the lower block, which uses a channel, thus causing a very small surface area for the head gasket between the channel and the cylinder, which accelerates wear. Spent $3,000 to fix this well-known design issue. Car at ~100k miles.

The vehicle was recalled. I took the vehicle to the dealer where it was purchased. It was serviced. The engine issue was addressed, so we thought. The repair/replacement parts did not remedy the issue, despite it being in the shop for over 6 months. The problem persists. It is overheating in a 5 minute drive. The local service department is saying there is no other remedy. They keep asking we bring it in for another diagnosis, but the problem is the same as the 47,000 other vehicles that have been recalled by this same issue. We purchased the car and have not been able to use it.

Engine failure due to coolant intrusion tsb22-2229 dealer said this type of failure is not covered by my extended warranty and ford/lincoln corp refuses to pay for the repair .