2017 Lincoln MKC Engine problems

The contact owns a 2017 Lincoln MKC. The contact stated that while his wife was driving 65 MPH, the check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that there was coolant inside cylinders #2 and #3. The contact was informed that the engine needed to be replaced. The engine was replaced, and the vehicle was repaired. The failure mileage was 45,000.

My 2017 Lincoln MKC equipped with the 2.0L EcoBoost has recently experienced a serious engine failure and requires engine replacement. It developed an engine problem while driving on at least two occasions and is no longer reliable or safe to operate. No prior warning messages were observed on the vehicle. Fortunately, I was able to pull over on the side of the road and I observed smoke coming from the engine. I was then concerned about the safety of an unexpected engine failure while driving, which might cause...

The contact's wife owns a 2017 Lincoln MKC. The contact stated that while driving at various speeds, the engine was running rough. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the #3 cylinder and spark plug had seized and there was water intrusion into the engine. Upon further investigation, the contact associated the failure with NHTSA Action Number: DP26008. The contact stated that the engine was previously replaced by an independent mechanic with parts from the local authorized dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 101,989.

Check engine light on. Codes P0316, P0300, P0301, P0302. Technician confirmed via scope coolant intrusion on cylinder 1 and 2. Technician stated it is known issue with this engine and recommends a new engine for $16,169.92. This has been an ongoing issue for the past two years.

My husband and I own a 2017 Lincoln MKZ that was purchase new in 2018. It is equipped with the 2.0L EcoBoost engine, with approximately 69,000 miles. It has been meticulously cared for! Before the diagnosis, I noticed that when starting the vehicle and backing up, the engine would jerk slightly until I stepped on the accelerator to proceed. The check engine light then came on, which prompted me to take the vehicle to the Lincoln dealer for diagnosis. The servicing Ford/Lincoln dealer, Sugar Loaf Ford in...

Coolant intrusion into number 2 cylinder requiring full engine replacement of my 2017 my 2.0l eco boost engine

Head gasket failure where engine coolant leaked internally into the engine cylinders.

For the last 17,000 miles, the engine light has been on. We got it checked out and there is coolant and cylinder three we change the cylinder thought it was a misfire, but the problem keeps occurring and we found out information that those engines are bad.

Check Engine Light present. Took car to Ford dealership. Formal diagnosis from Ford dealership: Coolant intrusion present causing misfires, specifically in cylinder 4. P0304 and P0316 codes present. This is a known manufacturing issue; however, Lincoln customer service refuses to acknowledge the problem even exists. Upon talking to the Ford dealership service members, they stated that this is a common issue. One of the service members stated he has already dealt with multiple vehicles with this exact problem this...

I am filing a formal safety complaint regarding my 2017 Lincoln MKC equipped with the 2.0L EcoBoost engine (VIN: [[redacted]]). The vehicle has experienced a severe, progressive engine failure caused by internal coolant intrusion into Cylinder 1, directly matching the structural design defect detailed by the manufacturer in Technical Service Bulletin TSB 22-2229. This defect allows pressurized engine coolant to continuously leak directly into the combustion cylinders while driving and during engine rest. This...

Check engine Light P0302 Engine Misfire Cylinder 2. I noticed Low Coolant in the overflow tank. Went to dealer They did a pressure test found coolant Intrusion inside Cylinder 2 open TSB 22-2229 Car or SUV if coolant gets into cylinder can cause engine failure

About 3 weeks ago, I was driving, and a red flashing light came on, signalling that my coolant was low. I bought radiator fluid and put it in up to the fill line. I visited my daughter, which is 11/2 hr. away. I checked the radiator reserve when I arrived at her house. The reserve was empty again. I brought it to a local mechanic shop. They diagnosed that I have coolant intrusion in the engine. They said I would need to pay for a new engine around $8800-$9200. I had purchased a lifetime extended warranty when I...

The contact owns a 2017 Lincoln MKC. The contact stated upon starting the vehicle, the vehicle idled roughly, and there was white smoke coming out of the exhaust. The contact stated that the vehicle was experiencing excessive coolant consumption, and the low coolant temperature warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced due to coolant intrusion. The vehicle was then taken to an independent mechanic, where it was...

Lincoln MKC 2017 Engine failure due to Coolant leak. Bought new Lincoln MKC 2017. The current mileage is 52, 500. Upon Starting, engine would shake for about 10 seconds. The Engine light would come ON. Engine light would turn OFF and ON for few weeks. The Dealership diagnostic indicated code P0301. I was advised Full Engine replacement. Currently the Engine is not starting at all. I have heard it's a design issue with the Engine. I have contacted multiple Lincoln dealerships, and each one has its own engine replacement costs. Lincoln Concierge declined my request to help in anyway although it seems to be a design issue with the Engine.

I took my vehicle to the local Ford dealership for service due to a check engine light being on. They pulled the spark plug and found the cylinder full of coolant and found TSB-22-2229. I called Lincoln and was told they wouldn't assist me because I fell outside their time and mileage limits. This issue should have been a recall due to their defective engine design. Engine replacement is very costly and the company should take responsibility for this flaw.

My vehicle started stuttering & shaking when starting. Then the check engine light came on. It was diagnosed with cylinder 2 & 3 misfire. All spark plugs & coil packs replaced. It got better for about 3 months then the problem came right back. Have replaced coil packs multiple times. Took to dealer who said cylinder misfires were caused from coolant leaking & the only fix was to have engine replaced & quoted $11000. This started at about 95000 miles. Vehicle has had perfect maintenance, all oil changes done on Schedule. Dealer said motor can lock up at any moment & this was a manufacturer error.

Issue Description: The vehicle developed a check engine light and was diagnosed with a P0302 cylinder #2 misfire. The condition persisted after basic troubleshooting, and the vehicle was taken out of service to prevent further damage. The vehicle was subsequently brought to an authorized Lincoln dealership for diagnostic evaluation. The dealership confirmed that the vehicle requires a full engine replacement due to internal engine failure. The estimated cost of repair is approximately $9,500-$10,000. This...

In 2023 antifreeze was found in the engine cylinder chambers causing the engine to run rough. We purchased the repair/replacement of a new head gasket at a cost of 3500.00. Now, it is Apirl 2026 and we have developed the same issue plus internal oil leaking in the turbo. Our repair shop says we need to replace the engine and the turbo unit at approx cost 11,200.00 (parts and labor). We have come to learn that this Ford 2.0L 4cyn EcoBoost engine has been found to have a design defect causing regular head gasket failure. So, this is our complaint about this engine and product built by Ford Motor Company. We have come to realize we own a very unreliable vehicle built by Ford.

The engine in my 2017 Lincoln MKC (2.0L EcoBoost) has a documented manufacturing defect where the cylinder block design allows coolant to leak into the combustion chambers. This has caused persistent, unexplained coolant loss and rough engine performance on cold starts since February 2025, matching the diagnostic criteria in Ford TSB 19-2346. The defective engine assembly is available for inspection. This condition creates a significant safety hazard, including sudden power loss (Limp Mode) in traffic and a risk of...

Related to previous recall [[redacted]] I had the recall repair done. But my car with only 86,744 miles now has coolant in cylinder 3 and it's misfiring so badly the car shouldn't/can't be driven. Dealership says the entire engine needs to be replaced. I have NEVER had a car this low of mileage that an entire engine needed replacement. This is a design flaw in the 2.0 ecoboost and I now have a probably 20,000 or whatever it may have been worth when it ran... Paperweight. It's just sputtering and spitting out loads of smoke as described in original TSB. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Lincoln MKC. The contact stated that while driving at an undisclosed speed, the vehicle sputtered with a misfire coming from the engine, with the check engine warning light flashing on the instrument panel. The vehicle was taken to the dealer where it was diagnosed with coolant intrusion in cylinder #3, which caused the engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 111,000.

Head gasket leaked coolant into the engine and now the engine is not working and needs replaced.

At approximately 64,000 miles my engine light came on and I took it to a shop. Cylinder 2 was misfiring so we changed the spark plugs and coils. At 67,000 miles light came on again with same issue and while having my oil changed they noted it was unusually dirty. I changed out plugs and coils again. At 72,000 miles light came on again and I took it to a different shop and learned I had a crack engine block, a problem with these vehicles with ECO boost. I was told I needed a new engine and the only thing I could do...

After a repair/service visit at a national auto repair chain, my 2017 Lincoln MKC developed ongoing severe drivability and safety issues. The check engine light began flashing (active misfire), and the vehicle was unsafe for highway travel due to risk of loss of power/engine damage. Independent shop documentation reports cylinder #4 misfire (P0304) and additional engine timing-related code(s), low oil condition, and notes indicating internal engine damage and that the engine may require replacement. The vehicle...

My Lincoln MKC 2017 is having a recurring problem with a misfire in the 3rd cylinder due to a hood gasket, a crack in the coolant, and leaking on the sparks and coils. I have had my mechanic work on and look at it, and it is a manufacturing defect. When I called, there was no recall listed for my vehicle except the backup camera. However, when you look at Kelly Blue Book, it says there is more than one engine recall and issue, which is exactly what is happening to my Lincoln. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.