2018 Nissan Leaf Electrical problems

research, there is a recall out for 2019-2022 Nissan leafs with possible fire related issues because of the batteries and the P33ED code that i am getting is directly related to this recall. I believe I have a recalled battery in my vehicle but Nissan won't offer any assistance because my VIN isn't necessarily recalled. I feel unsafe to charge or operate this car, especially under any type of speed or load and Nissan is offering no assistance in repairing the vehicle or even verifying the battery manufacturer date.

really cold days, but not nearly as bad so i lived with it. At about 100k miles, it started doing a very similar issue, but way worse, and at any temperature. It got so bad i couldn't drive without the battery always being fully charged. Took it to the first dealer who said nothing is wrong with it even though i had videos of it happening. I then called nissan corporate and opened up a case and asked them directly "before i take it to another dealer for a second opinion, is this something that you can offer financial assistance with" and that lady said "yes, we can offer assistance for sure". I took it to another dealer who did some tests and confirmed it needed a battery. Shortly after that, the car now shuts down under even a slight load. A small backroad hill will shut it down and I get an error code P33ED now. This code is related to a battery recall on 2019- 2022 models that can cause a battery fire! After almost 2 months of nissan saying they didn't have the part available, they just informed me they won't offer any assistance because im out of warranty! Not only did i have the battery replaced once, but it has already failed a second time, and they installed a battery that is now recalled but wont honor the recall because my vin is a 2018. I am beyond frustrated with their lack of care about my families safety since this could catch fire! I am hoping to reach out to you for some additional guidance on this situation. Thank you.

P0AA6-1A 0B. Dealer service personnel identified the condition as an internal short in the pack. Due to the fire risk associated with an internal short in a lithium-ion traction battery, I declined to take possession of the vehicle, which remains at the dealership. An internal short can lead to thermal runaway without warning, whether the vehicle is being driven, charging, or parked. The failure of a factory replacement battery pack in 16 months, following the failure of the original pack, indicates a potential manufacturing or design defect in Nissan's service replacement HV battery packs for this platform. I am reporting this so NHTSA can evaluate whether other Leaf replacement packs exhibit similar internal short failures. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

was able to be recharged. No repair was recommended. The contact related the failure to the variable voltage control system and the 12-Volt battery amp-hours (Ah). The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 79,545.

occurred on three occasions where the vehicle just randomly shuts down on the freeway in the middle of the highway. This is a serious concern that will definitely cause injury or death. I attached photos of two occasions when the battery discharged almost immediately, and the one photo shows on the vehicle was completely disabled. I have more supportive photographs and computer printouts from diagnostics if requested..

temperature less than 15F and the vehicle has been outside for 8+ hours), less than 60% charged, and put under high load (going up a steep grade/60MPH+) the vehicle will register a battery discharge rate of ~5%/second and continue until the vehicle puts itself into turtle mode, the load is reduced, or I assume, shut off. Battery discharge is "phantom" where the vehicle, when under less load (i.e. slower/slowing), will return to a higher charge, and when no load (i.e. stopped), will return to close to the original charge. Depending on how long the high load is maintained it can drastically reduce the real state of charge on the battery. The Nissan dealership identified it as at least one bad battery module, but no fault codes were registered by the vehicle outside of experiencing turtle mode. This issue forces the driver to slow down to reduce load on the vehicle and abrupt speed changes may be required to keep the vehicle operational. This can put the driver into a dangerous situation of being forced to slow down regardless of road conditions or other driver behaviors. If all of the conditions for the battery listed in the first sentence are met, the vehicle will register a rapid battery state of charge decline, it may indicate turtle mode is active (helps reduce battery load), and it will indicate low charge around 10% state of charge. I have personally experienced all of this as the driver, and any assumptions I have made I have identified.

into the charger, and got an error message "EV System No Power", and they couldn't drive it anymore. Sometime after that there was a thermal event that caused the Power Distribution Module to explode and for soot to pour out of it. These incidents are described by the technician Ryan in these videos [[redacted]] Nissan indicated that the electric power train is no longer under warranty. Our Q:When did you receive the car? ([[redacted]] repair order opened [[redacted]]) When did you first start working on the car? [[redacted]] When did the thermal event occur? (unsure of occurrence date) When did you replace the 12 volt battery? [[redacted]] when were you told to replace the high voltage battery? [[redacted]] when did you replace the high voltage battery? [[redacted]] Is the replacement high voltage battery a new battery or a used battery? (new battery) Has the replacement high voltage battery been maintained at a charge or is it at 0% charge? And what charge is it at now? (SOC unknown at this time) when were you told the pdm needed to be replaced? ([[redacted]] after HV battery was installed and further diag was performed) When did you replace the pdm? (not yet completed -- were in process but stopped due to BUS bar bolt discovery) Vehicle was left unattended with no HV warnings with service plug removed but inside vehicle with no cover over port to HV battery. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

tried to put the car back into drive but it was impossible and the dashboard read "EV maintenance needed". Of note, my entire battery was replaced less than 6 months prior and the Nissan Peoria (AZ) dealership reported no other issues with the vehicle. Upon inspection, the dealership reported the traction motor inverter needs replacement, and again there were no indications this was failing.

malfunction and the car needed to be repaired by the dealer, On March 20, 2023 the car was taken to the dealer. The dealer informed me that the car was unsafe to drive and would not, nor did they ever, return the car to me [with the exception of a one-week test drive that did not correct the reported issues]. On August 3, 2023 Nissan North America declared in writing that the car was a Lemon under Florida law. Nissan refunded the purchase price of the car. Both Carvana and Nissan North America have refused to fully compensate me for certain incidental expenses including auto insurance [required to kept active until title transfer] and unused monthly prepaid Carvana maintenance costs. These fees were assessed from March 20, 2023 until August of 2023. During a discussion with Nissan North America their agent disclosed that they intended to wholesale this car. My immediate concern is that a Lemon-declared car should be disclosed if it is even allowed to be resold.

but windows would fog up. I could not charge my vehicle in this error state either, so if I hadn't been close to home, I would've been in a potentially dangerous situation because it was cold out. The local Nissan dealership confirmed the error codes of P0AA6-1A (HV battery voltage system isolation) and P31E7 (restart inhibition) were present. They initially fixed this issue after nearly 5 months of the vehicle being in their shop. These codes, paired with the information I've read on the Internet, indicates others have had this issue before, and the normal repair involved replacing the traction battery (400v high-voltage battery), not these two components. The "Service EV System" came back less than 36 hours after paying for the repair. The 12v battery was also at a low voltage, which may have been related to the vehicle sitting for so long for service without being charged.

happened on 8/13/21. I was slowly reversing out of a parking spot at a crowded location, when I saw a car behind my vehicle. I went to brake (not hard brake just regular), and the brakes did not work. I continued to slowly roll back towards the car behind me. I tried pressing the brakes repeatedly and it would not stop rolling backwards. I then pulled the emergency brake and the car came to a stop. No lights appeared on the dashboard. I turned the car off and powered it on again and slowly moved forward into the parking space and tried reversing again. The car was driving completely fine just after. I had a short trip home & didn't drive the rest of the evening. I didn't charge the car as there was still 85% left on the battery. The next morning, the car would not start and a message showing "Service EV System No Power" appeared on the dashboard with multiple lights lit. I called a tow truck to take it to the dealer and they found that the 12v battery was completely dead. Battery light not lit on dashboard prior to the complete outage. The dealer said it was the 12v battery that was likely the cause of these incidents and they replaced it. The brake issues could not be reproduced at the dealer after the new battery installed. Also note, that I just had the vehicle in for a multi-point inspection in June where nothing was found to be faulty. They did recommend a brake fluid exchange, so this was done as well as tire rotation.

sos functionality is enabled by checking that the little light on the sos button is lit. 2. Press the sos button. 3. Press and hold the sos button while turning off the car. 4. The sos call will lock the screen of the car, and will stay that way until the sd card is removed and re-inserted. Tried reporting this to nissan, no response.