1995 Nissan Pathfinder Engine problems

It started not starting and a couple of times just died when I was stoped now it wont start at all . And theres a short somewhere the radio goes on and off.

Tl* the contact owns a 1995 nissan pathfinder. While driving approximately 50 mph, a clicking noise was heard from the outside of the vehicle. The failure recurred sporadically before progressing to a permanent occurrence. The vehicle was taken to an independent mechanic who advised the contact that the failure was contributed to the exhaust manifold, which required replacement. The vehicle had not been repaired. The manufacturer was not notified of the defect. The approximate failure mileage was 162,000.

1995 Nissan pathfinder xe frame rot, scaling and faulty manifold studs or manifold (related vehicle information: model year=1995, make=nissan, model=pathfinder). *Tr

Dt*: the contact stated while driving 25mph uphill, the carpet around the gear shift suddenly erupted into flames. The flames were extinguished by the driver with water and the authorities were not contacted. The vehicle was towed to the contact's home and later transferred to the insurance agency for inspection. Upon inspection it was determined the heat shield was missing from the catalytic converter and the floor board in that area was completely rusted through allowing extreme heat to contact the carpet. ...

Last february it was the right side exhaust manifold bolts. This year it was the left side. Fortunately I knew what it was when I heard that familiar ticking noise. Again, I'm told this is a common problem with the nissan pathfinder, and I could have severely damaged my engine had I not brought it in when I had. *Jb

Engine was making a ticking noise, so I brought it into the dealership and was told it was the right-side exhaust manifold bolts that had broken off. I was told this was a common problem, and if not caught in time would cause extensive damage to my engine. *Jb

1995 Nissan pathfinder frame broke in half.***No answer required***. *Mr on june 19th the consumer had all four pneumatic air ride shocks replaced along with all the belts and water pump. On the way home from having these repairs done the frame broke in half. The entire frame had rusted through. The consumer believes the frame was made with inferior metal. *Nm

While the vehicle was parked fluid was leaking from underneath the vehicle. Consumer took vehicle to the dealer for inspection, and mechanic determined that the manifold needed to be replaced. *Ak

Vehicle stalled while driving. When this occurred consumer coasted the truck off the road. Upon exiting the truck consumer noticed gasoline leaking out of the smog filter. Truck was towed to a mechanic after the fire department had secured it for travel. Mechanic indicated that one or two of the valves in the fuel system, and the fuel cap could be the cause. Both valves, fuel cap, and the smog filter were replaced, but the failure recurred.*Ak

Same problem as everyone else with a 1995 pathfinder - manifold bolts have broken and a very expensive repair is necessary. It's been bad for a long time and I've just ignored the ticking sound.*Ak

Exhaust manifold studs broke on passenger's side of engine. Found it a common problem that nissan won't fix. *Ak

BOLTS ON EXHAUST BROKE. *TT

@ 50K left manifold failure - replace/covered by warranty. @ 65K right manifold failure, not covered by warranty, paid out of pocket to replace. Now, @ 90k another manifold failure. *Nlm

Driver and passenger side exhaust manifolds have failed and have been replaced. Carbon monoxide was entering directly into the passenger compartment and forced me to pay the ~$900 to have them repaired. Attempting to receive reimbursement from manufacturer. *Nlm

Passenger side front most cylinder had one exhaust manifold stud break off and after carefully inspecting other studs on passenger side at least one more is broken. Seems like a common problem, but very expensive to fix also very frustrating!!! *Jb

The left and right exhaust manifolds warped.*Ak *jb

At my 60k service the mechanic diagnosed a faulty exhaust manifold and replaced it. Fortunately, this was covered by my extended warranty. I've come to realize that is was a common problem with nissan pathfinders although no recalls have been instituted. I'm concerned that this will reoccur again as my vehicle approached 100k.

EXHAUST MANIFOLD STUD BROKEN

Exhaust manifold bolts broken. Obviuosly nissan is aware that this is a constant problem for pathfinder owners. Their neglect at addressing this situation compounds my frustration. Wilson nissan in logan utah espects me to replace them at my cost every time they break, which could happen as soon as they are replaced. I suggest a class action lawsuit from all owners of these vehicles is in order to get nissan to address this problem. Had known of this I never would have bought a nissan product, and I never will again.

NO SUMMARY. DT

Exhaust manifold studs broke, causing exhaust leak on right & left sides of engine. *Ak

Exhaust leak at right exhaust manifold. Three studs failed allowing manifold to pull away from cylinder head causing head warpage. Fourth occurrence on same side of manifold.*Ak

Problem with exhaust manifold bolts that secure it to engine head. Nissan is aware of the design flaws. Manifold directs hot exhaust gas back into the exhaust system to be burned or expelled from the car. No recall, but nissan knows the angle of the manifold curve is misaligned. Gas hits the metal head on and overheats the manifold and studs. The heat warps the metal and shears the bolts which should keep the part secure.

Right side manifold failed, bolts broken in engine. This is a known nissan defect and subject of many complaints.*Ak

I was told by a mechanic that this an extremely common problem due to poor manufacturing and this problem is under investigation. Didi they ever do a recall? I was also told that if I fixed the manifold and head bolts that this problem would repeat itself. Is there any thing I can do ? Thank you.*Ak