- The problem
- Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. The morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, "throttle"; "off" or "front" and "on" or "rear" selecting the active engine control station. If a person operating the engine from the "rear" position (at the engine) fails to place the switch in the "off" or "front" position and the engine rpm was set to above idle during maintenance for example, when the bus is started from the driver's station the engine could change to the higher rpm resulting in unwanted engine power.
- The risk
- The bus could accelerate at a higher rate than anticipated increasing the risk of a crash.
- The fix
- Daimler will provide instructions to modify the wiring to the morse throttle control switch. This service will be performed free of charge. The safety recall began on april 1, 2010. Owners may contact daimler buses at 1-800-716-7466.
Vehicle safety record
1992 Orion V Problems, complaints & recalls
No owner complaints about the 1992 Orion V have been filed with NHTSA. It is covered by 2 recalls, the latest in January 2010 for the pedal / hand lever(motorcycle).
NHTSA data checked
AFar fewer problems than a typical V year, for its age
- Complaints
- 0
- Recalls
- 2
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
1992 Orion V recalls 2
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain transit buses equipped with lift-u wheelchair lifts, it is possible for a person to wedge their feet under the solid bar barrier linkage.
- The risk
- While sitting in a wheelchair, a person with no shoes and who does not have control of their feet could twist their feet and get them forced under the linkage which could result in an injury.
- The fix
- Daimlerchrysler commercial is working with lift-u to repair these buses (please see 06e-093). Owners will receive a free repair kit along with installation instructions free of charge. Owners may contact lift-u at 209-838-2400 or orion bus at 905-403-7807.
What owners say
Be the first V owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 1992 Orion V yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Orion V: every year compared
All V years1992 Orion V vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 1992 Orion V | 0 | 2 | A | |
| 1992 Orion I | 2 | 2 | F | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 1992 Orion V
Does the 1992 Orion V have any recalls?
Yes - NHTSA lists 2 recalls for the 1992 Orion V: pedal / hand lever(motorcycle) (January 2010); equipment adaptive / mobility (February 2007). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 1992 Orion V had?
None have been filed with NHTSA so far.
Is the 1992 Orion V a reliable vehicle?
Its Safety Index is 80 out of 100 (grade A: far fewer problems than a typical Orion V year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Orion V years have the most complaints?
2000 (1), 2002 (1). See every Orion V year compared.
What should I do if my 1992 Orion V has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data