2017 Tesla Model 3 Problems, complaints & recalls

My 2017 Tesla Model 3 Long Range (RWD) makes a knocking/thumping noise from the front driver-side suspension when turning the steering wheel at very low speed (under 5 mph) while the vehicle is pitched on an incline or decline - for example, entering or exiting a parking lot via its ramp. It does not occur when turning on flat ground. I first noticed the noise in fall 2025, a few months before taking the vehicle to Tesla. Tesla Service ([[redacted]]) took the car in for this complaint and on [redacted] replaced the...

Seats Front passenger safety restraint system issue/ Service is required/Service is required

My Tesla repeatedly displayed a "Passenger Safety Restraint" warning related to the front passenger restraint/airbag system. Tesla Service Center in Los Gatos, California attempted multiple repairs over several visits. The first repair identified a pinched and improperly routed passenger seat harness associated with the restraint system. Tesla stated the issue was repaired and tested. The warning later returned. Tesla then replaced the front right seat harness assembly and lap pretensioner. The warning later...

I am writing to file a formal safety complaint against Tesla, Inc. regarding a software update failure that has disabled legally required vehicle functions on my Tesla for over two years. For more than 26 months, my vehicle has been unable to complete a software update through Tesla's over-the-air (OTA) update system. As a direct result of this failure, my vehicle's display screen does not function for the first several minutes of every drive. This prevents me from accessing my speedometer, turn signals, and other...

I received an error about the occupant classification system and a safety restraint fault. These are due to known manufacturing defects. Addressing these concerns was expensive and also required a replacement of the front passenger airbag.

En primer lugar decir que el VIN utilizado es completamente aleatorio. Esta notificación está dirigida para todos los fabricantes de vehículos eléctricos y fabricantes de baterías. Actualmente los diferentes medios de comunicación y redes sociales no paran de reportar incendios en las baterías de los vehículos eléctricos, con el peligro que esto representa para personas y bienes colindantes. Estos incendios están producidos en gran medida por la deformación que sufren las baterías a lo largo de su vida útil, con...

Hello. I am following up with the previous safety report I submitted for my vehicle. I just received an updated repair estimate citing the parts that will need replaced (pdf attached). I also confirmed with the service advisor that the functionality of the safety restraint system may be impacted by this issue, however, Tesla still wants to charge drivers $1,300 for this repair.

There is a warning on my car saying "front passenger safety restraint system fault". The Tesla service center says the fix requires an air bag replacement and to replace the seat sensor. Does this not impact the safety of the passenger? This is the second model 3 I've owned that continuously has this fault. I feel like this model should be recalled since it is such a widespread issue. I dealt with this warning light for 2-3 years because Tesla wants to charge >$1,000 for the replacement of these parts. I'm...

I purchased a new 2017 Tesla model 3 in late 2017, drove it 135k miles and suddenly had issues with the battery cooling fan staying on all the time and the interior cooling not working. The Tesla service center found the condenser completely blocked with road debris. This was possible because of a design flaw in the condenser being horizontal and receiving unfiltered air directly scooped from the vent below the grill of the car. This design flaw is present in all model 3 and model Y as I can see but, the amount of...

My car has been having this issue since it was purchased in 2018. An alert appears on the screen which says, "Front Passenger Safety Restraint System Fault/Service is Required." I had the car serviced four times by Tesla under warranty. It has now appeared a fifth time and Tesla says the airbags need to be replaced for over $1,600. The prior repairs included replacing wiring harnesses and occupancy sensor.

I had just finished Supercharging my vehicle from 50% to 80% and when I entered the car to drive home two warnings showed up 1. Steering assist was reduced and it might be more difficult to drive; and 2. Lane departure avoidance warning was not working. I did a hard reset twice - (foot on the brake while pressing the two steering wheel 'wheels') and began driving the 10-15 minute home. After an incredibly scary and difficult drive down a circular driveway, and great difficulty turning the wheel to make a...

Within a week of posting a complaint here about phantom braking while in autopilot, my autopilot was disabled. Does the NHTSA share VIN numbers with the manufacturer? Because that sure felt like retaliation by Tesla

Back windshield spontaneously cracked from the heat.

Safety Restraint System Fault in front passenger seat alert. Appears to be a common occurrence in Tesla Model 3 cars. Not covered under warranty to due to only 50k mile coverage for safety system, but the failure seems quite common. Required a replacement seat and replacement airbag. Many users reporting the same issue in the car.

Feb 25 around 4pm PT we were driving north on US Hwy 101 using the basic cruise control feature of our Model 3. Based on our settings I believe this would be considered adaptive cruise control, but I'm not sure. Enhanced Auto-Pilot was not in use. On a largely open highway, in particular with no one in front of us, and thankfully, no one close behind us, the car suddenly started to lose speed, not brake, just lose speed. I pressed the right-hand button on the steering wheel and called out "report bug" so there...

The vehicle frequently applies emergency braking when approaching overpasses at night while driving on highways at night at normal speeds. This happens about once per 100 miles or so.

My tesla model 3 , parking break do not release. so i can not go front or back!!! i thing they had recall about that long time ago. it happend every month once. you get stuck for 2 hrs or so and then it get atomatically release!!!

The contact owns a 2017 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 21V00D000 (Electrical System, Visibility, Back Over Prevention) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

My rear glass cracked. However, there was no damage to suggest an impact of any sort. I looked carefully and saw there was no damage to suggest this was caused by an impact. I took the car to the Tesla dealership and they also examined the glass and agreed that there was no impact of any sort that would have caused the glass to crack. They then told me that they have seen this on multiple Tesla vehicles and believe it's a manufacturing defect possibly related to the defroster. They refused to cover it under any warranty as I was out of the warranty period.

Experiencing unexpected braking on freeway while on cruise control. Car brakes for apparently no reason. There is no warning, vehicles in sight, on clear sunny day. Has braked up to 3 times/hr on two different days on road trip. No indicators say that anything is wrong with the car or its cameras. It is jarring and scary for both driver and passenger. Collecting info for Tesla service appt in August. Read info of phantom braking for newer Teslas. We drove this same route in this car in summer of 2019 and didn't experience phantom braking.

Many phantom braking incidents both on autopilot and in adaptive cruise control mode result in surprising (and frightening) sudden braking for no reason. In high traffic conditions, this could lead to a possible rear-end collision. The adaptive cruise control has become so unstable in the last few months we will not use it. As this is a mature feature that used to work nearly flawlessly this is very frustrating to go backwards with an update.

Essentially all of the safety and convenience features repeatedly shut off. Lane departure, autopilot, regenerative braking, VSC, emergency braking, airbags, traction control, automatic vehicle hold, stability control, and a few others stopped working on multiple occasions. This definitely put my life and my family's life at risk. The problems were reproduced and confirmed by the dealer and the vehicle was inspected by the manufacturer. All of the warning lamps and messages only popped up when the failure...

Tesla vehicles have driver profiles to adjust seats automatically when a driver taps the brake pedal after entering the vehicle. A recent software update 2021.44.25.2 took away any on-screen indication of what profile the car is trying to set the seats to. There is no longer an on-screen STOP button, nor does a menu pop up giving a driver a chance to select a different profile. The result is that a driver has no expectation that seats might continue to move past the expected point, and since there's no longer an...

On August 9th, 2021 I was traveling on Interstate 40, in NC, at MM 103 at approximately 70 mph. when with no warning the Main Control Unit (MCU) went blank. Adaptive Cruise control, speedometer were not operable or could not be seen. The MCU reset after a brief (5 second) pause. I immediately placed a service request for August 25th with Tesla. Tesla updated the firmware and performed standard maintenance on August 25th. See attached screenshots. On October 26th, at approximately 505 in the afternoon, I was...

The Autopilot system on my vehicle malfunctioned, leading to the vehicle colliding into a stationary road barrier at highway speeds. The vehicle sustained severe damage as a result of the collision and was no longer operable.