2016 Ford Explorer Steering problems

What component or system failed or malfunctioned, and is it available for inspection upon request? Yes How was your safety or the safety of others put at risk? Yes: While driving on [[redacted]] at highway speed, my vehicle suddenly began to swerve, causing a significant loss of steering control and creating an unsafe driving condition. Concerned that I had experienced a flat tire, I immediately pulled over to inspect the vehicle. Upon inspection, I found that none of the tires were flat. Believing it was unsafe...

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The exterior B-pillar trim on the side of the vehicle became detached while the vehicle was being driven. After the trim became loose and was temporarily secured by a Ford dealership, the vehicle's security system malfunctioned, the tailgate would not open, and the vehicle would not shut off normally. The trim piece is currently taped in place. 2. How was your safety or the safety of others put at risk? The trim...

Approximately 3 years ago, while driving my 2016 Ford Explorer on a [[redacted]], warning chimes sounded and a power steering/steering assist fault message appeared. Electric power-steering assist then stopped functioning and the steering became extremely difficult to operate. I slowed down and was able to maneuver safely off the freeway. I shut the vehicle off, opened the driver's door, waited approximately 45 seconds and restarted it. Normal steering assist returned. Shortly afterward, I took the vehicle to...

Hello. I purchased my car in 2018. 2-3 years later, the power steering would randomly go out while driving - on the highway and city roads. This could happen once and then not again for 6+ months. When this happened a message would display about a "steering assist fault, service now". I found that if I pulled over, turned the car off and then on, it would generally work again. We had the vehicle in to 3 separate repair shops between 10/2022 and 10/2025 and no one could diagnose the issue as they needed it to...

2016 Ford Explorer, VIN [[redacted]]. Filing against Planet Ford Dallas regarding incomplete Regional Program 21R01 (Rear Toe Link Replacement), tied to Federal Safety Recall 21V537. May 11, 2026: Vehicle presented for 21R01 service. May 15: Returned with recall marked complete in Ford's system. 21R01 mandates replacement of both rear toe links, alignment check, and rear toe adjustment. None of these steps were correctly completed. Dealer has since acknowledged to me that the toe link was not replaced correctly,...

The electronic power steering failed Yes its available for inspection My child and my safety were put at risk when I warning came up and said "steering loss, stop safely" and the steering wheel was locked. The problem was still there when it was brought into Ford service center Nothing prior to the warning

The steering on my Explorer has seized up making it very dangerous to drive because you can not hardly get the steering wheel to turn.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became difficult to turn to the left or to the right. The contact stopped and turned the vehicle off and restarted the vehicle, and the power steering functionality returned. The contact stated that the failure had occurred twice and during the second failure the check engine warning light illuminated. The contact had not taken the vehicle to a local dealer or an independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 79,000.

The car had ongoing issues with a warning sensor that stated Steering Fault - Service Now. There was also a clinking noise when driving straight and then turning right. Took car to dealer repair show and they ran a diagnosis report (I assume they did). It was reported that it was an internal fault with strut bearings and installed a bracket that was suppose to remedy the issue. Since then I would get the Steering Fault warning but it would happen and then not show up for several months. Recently 8/2025 the...

Dear NHTSA, I am submitting a formal safety complaint regarding my 2016 Ford Explorer (VIN: [[redacted]] .) Build Date: (08/15.), Mileage (115,262.). My vehicle has experienced a steering rack failure, which poses a serious risk of loss of steering control. I am aware of multiple recalls (such as 20v-675 / Ford 20S62 and 21V-537 / Ford 21S32) Addressing rear suspension toe link fractures in 2016 ford explorers. These recalls cover vehicles built in the same timeframe as mine, but my VIN is not included. This...

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle lost power steering assist functionality, and the steering wheel was stuck while attempting to turn the steering wheel to the left or the right. There were no warning lights illuminated. The contact spoke with the dealer and was informed that the power steering assist had failed and needed to be repaired. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 97,000.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at approximately 35 MPH, the steering wheel became stiff and did not drive as intended. The contact stated that the next morning, she observed a sound emanating from the steering column. The check engine warning light was illuminated before the failure. The vehicle was not diagnosed or repaired. The contact believed that the failure was associated with NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was not notified of the failure. The failure mileage was approximately 156,580.

The contact owns a 2016 Ford Explorer. The contact stated that while in reverse(R), the vehicle failed to turn to the left or right, and the steering wheel was stiff. The contact stated that when the vehicle was shifted into drive(D) and pulling into a parking spot, the steering wheel was stiff. There was no warning light illuminated. The contact stated that the vehicle was turned off and restarted without the failure recurring. The vehicle was taken to a dealer for maintenance on the brakes, and the vehicle was...

I was driving the family and about to enter the highway when my steering started to feel like there may be a problem. The steering started to feel like it was sticking. I turned around and headed back home (about 4 miles) by the time I entered my street, steering failure warning lights started on the dashboard. I had to come to an abrupt stop because the steering wheel would not turn to pull in my driveway. We had to dolly the rear of the car over so i can pull straight into my driveway. I can not even imagine what would have happened if I did not turn around to head home. If this happend on the highway or on a ramp, I could have become devestating.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The power steering unit failure warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with a failed electronic power steering rack. The contact was informed that the electronic power steering rack needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic where it was diagnosed...

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic and was diagnosed with electronic power steering control module failure. The contact was informed that that the independent mechanic found that the EPS control module was water damaged. The...

The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign numbers: 24V031000 (Structure) and 25V347000(Structure); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. Additionally, the contact stated that while driving 40 MPH and making a right turn, the vehicle lost power steering functionality. There was no warning light illuminated. The vehicle was taken to...

Steering gets really hard and jerks acts like the steering isn't working

I was at Apple Ford of Lynchburg, VA when I grabbed the steering wheel to exit the vehicle when the steering wheel came loose and began to wobble up and down, making the car impossible to control safely. The Service Department and I came to the conclusion that this may represent an apparent safety issue that must be addressed.

The contact owns a 2016 Ford Explorer. The contact stated while driving 60-65 MPH, the vehicle experienced a loss of power steering functionality. The contact stated that the message "Power Steering Failure - Stop Driving Vehicle" was displayed. The traction control warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed with internal steering gear head failure. The dealer performed the steering gear replacement and...

The contact owns a 2016 Ford Explorer. The contact stated that while driving at various speeds, while attempting to make a left or right turn, there was a popping sound coming from the steering wheel. Additionally, while driving on the highway at 70 MPH, the vehicle failed to exceed 70 MPH. The contact stated that there was an abnormal burning odor entering the cabin of the vehicle with the TPMS warning light illuminated. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 121,000.

The contact owns a 2016 Ford Explorer. The contact stated that while reversing out of the driveway at approximately 1-2 MPH, there was a loud, abnormal humming sound coming from the vehicle. The contact stated that the vehicle was pulling to the side. Additionally, while driving at an undisclosed speed, the vehicle was vibrating abnormally. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 29,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle experienced a loss of power steering assist. No warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 144,337.

Water pump

The contact owns a 2016 Ford Explorer. The contact stated that while turning the steering to the left or right while driving at various speeds and while the vehicle was idling, the steering wheel seize approximately a quarter way into the turn. The driver had to manually turn the steering wheel to continue the turn or to merge. The failure occurred intermittently but became more persistent. There were no warning lights illuminated. The contact called the dealer who confirmed that the VIN was not under recall. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000.