2016 Ford Explorer Visibility problems

25V347 and 24V031 I recieved a notice of the first recall in February 2024. Over the Summer of 2024 and 2025 both the A-pillar and B-pillar trim has melted and become detached from the vehicle during high heat warnings and during my commute to work on the interstate 60 miles each day. Parts from the vehicle flew off at high rates of speed and were at risk to others on the road. For 2.5 years now I have driven a duct taped windshield on both drivers and on the passenger sides windows and on the tops of the door...

one fell of window right side when driving on right side of window i tried to glue it back on don't think it will hold don't drive it much now went to ford dealer several time always told part is not available why it is a 2016 after 10 years should replacement parts not be available

I have been put off every month for over a year to have this fixed. It is a safety risk. Not only does the recall state the trim can come off and cause a crash, the rubber around both sides also keep coming loose and flapping on my windshield which causes interference with my view of the road. I am not sure why a safety recall was issued in 2024 but has still not been able to be resolved by 2026. They say the parts are not available but they should be making them available for any issue that can cause crashes and harm people.

The contact owns a 2016 Ford Explorer. The contact stated that while the vehicle was parked, the rear glass unexpectedly shattered. There was no impact on the windshield to cause it to shatter. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000.

Opened driver door to exit vehicle and heard a loud POP! Noticed rear window had exploded. Glass flew outside behind vehicle and continued to fall in rear of vehicle. Defrost was not in use. It was single digit temp out.

There have been EXCESSIVE delays with the repair of the A-Pillar trim. This item flew off of our vehicle while traveling down the highway at 70mph. THANKFULLY this piece did not impact the car behind us. This piece has now been missing for over 14 months. Numerous inquiries placed to dealerships and being told that the piece is still not available is not acceptable. Please encourage Ford to do better and make these pieces available for repair.

Backup camera is cloudy/foggy. Brought it to ford service department attention in regards to Issue Date 2022-08-26 Campaign 22S51/22V644 Per Fullerton Ford, they would not participate. I feel this is a visability issue when backing up and would like Ford to also consider 2016 ford Explorer in this recall since it is a safety issue

The contact owns a 2016 Ford Explorer. The contact stated that while driving in the rain, water leaked inside the vehicle from the dome light. No warning lights were illuminated. The contact stated that the moonroof failed to function as intended and was no longer able to be opened. The contact stated that there was mold on the front driver's side and front passenger's side seats, as well as inside the cupholders. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not...

The contact owns a 2016 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure). The contact stated that water was leaking onto the passenger's side floorboard and passenger's side door, causing an electrical short with the windows. The contact stated that the window was stuck. The contact left the windows opened to air out the vehicle. The contact used duct tape to secure the structure. There were no warning lights illuminated. The local dealer...

Windshield seal flies out from under the pilar molding and smacks windshield and passenger window.

The contact owns a 2016 Ford Explorer. The contact stated that water had entered the vehicle, and the inside of the windshield was freezing. There was an abnormal sound coming from the vehicle. The contact stated that the defrosted was inoperable. Additionally, the TPMS warning light was illuminated. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was towed to the local...

Driver seat moves all the way forward on its own and the side view mirror moves out of range. This has happened while in the seat and car running. It happens intermittently. It scares the heck out of you and pushes you all the way into the steering wheel which makes it impossible to steer. You have to be quick in order to stop it and because it startles you when it happens the reaction time is not immediate. Very scary indeed!

Molding on front windshield is damaged and coming off affect visibility

The moonroof malfunctions and can be stuck in the open position. The drain plug for the moonroof can easily get clogged causing water to back up into the overhead structure. This causes water to fall onto the driver and passengers. The water flows from the overhead area, the side pillars and onto the floorboards. The electrical components are then compromised and the motor that controls the moonroof stops working. In my situation my moonroof was stuck in the open position for several days. I live in Florida...

The contact owns a 2016 Ford Explorer. The contact stated that while driving 30 MPH, the A/C unit became inoperable. The vehicle was driven to a dealer and an independent mechanic to be diagnosed. The contact was informed that there was a leak in the A/C unit. The contact was informed that the A/C unit needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 19,000.

Trim around windshield becomes loose on highway and rattles against windshield and rubber seals have started coming loose

The contact owns a 2016 Ford Explorer. The contact stated that the sunroof failed to close. The seat belt warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the sunroof motor had failed and needed to be replaced. The vehicle was not repaired. The dealer informed the contact that the parts were on backorder. The manufacturer was not contacted. The failure mileage was approximately 136,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact became aware that the sunroof had started to detach and had sunken into the interior of the vehicle, creating an opening that allowed water to leak into the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the sunroof motor. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 116,000.

The contact owns a 2016 Ford Explorer. The contact stated that the air bag warning light was illuminated. The contact stated that there was windy sound coming from the front passenger's side door while driving. Additionally, the contact stated that there was water accumulated between the front driver's side door and the body of the vehicle, which caused water to pour inside the vehicle while opening the door. The contact also noticed that water was leaking from the driver's side of the windshield during inclement...

While driving on the highway, windshield trim flew off (2 different times, passenger and driver side). It scared me at first when it started to come loose because it flapped around and I wasn't really sure what was going on. And can't pull over or slow down on highway. When it broke off, it flew up in the air and almost hit another car. I was distracted trying to see what it was and where it landed behind me. So definitely a safety concern. Total repair cost $650

when traveling at highway speed the side fins fly off. i have had them replaced 3 times now at dealership. thank God there was not someone behind me - especially on a motor cycle it could of killed them

All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.

I was driving my 2016 Ford Explorer on I-65 October 19, 2023, in the afternoon. I thought something flew off of one of the two semis in front of me and hit my windshield on two separate times, within a few seconds of each other. When I arrived home, I checked to see if I had any damages, and I was surprised to see pieces missing from the passenger side of my windshield. This morning, October 20, 2023, I went to a local Ford Dealership and was informed there is no recall regarding the upper and lower pillars...

The contact owns a 2016 Ford Explorer. The contact stated that after it had rained, water entered the vehicle through the sunroof and would accumulate inside the roof of the vehicle. While coming to a stop while driving, the water would flow to the front of the vehicle and leak inside the cabin through the ceiling light console. The contact had taken the vehicle to a dealer on multiple occasions where they replaced the flooring and the sunroof; however, the failure returned after each repair. The vehicle was also...

The windshield trim blew off while driving on the Highway. Happened so fast I couldn't tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.