- The problem
- Subaru of America, Inc. (Subaru) is recalling certain 2016-2017 Outback vehicles. A replacement air bag control module may have been installed that is not compatible with the passenger air bag module, possibly affecting air bag deployment.
- The risk
- In the event of a crash necessitating passenger frontal air bag deployment, the air bag may not deploy properly, increasing the risk of injury.
- The fix
- Subaru will notify owners, and dealers will replace the passenger air bag module, free of charge. The recall began February 3, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUX-09.
Vehicle safety record
2016 Subaru Outback Problems, complaints & recalls
Owners have filed 643 complaints about the 2016 Subaru Outback with NHTSA, most often about the electrical system (309) and the visibility & wipers (91). Those complaints describe 22 crashes, 3 fires and 13 injuries. It is covered by 4 recalls, the latest in December 2019 for the air bag / restraint control module. For comparison, the 2015 has 509 and the 2017 has 921.
NHTSA data checked
FFar more problems than a typical Outback year, for its age
#14 most complained-about 2016 vehicle
- Complaints
- 643
- Recalls
- 4
- Crashes
- 22
- Fires
- 3
- Injuries
- 13
- Deaths
- 0
Most common 2016 Subaru Outback problems
Share of all 643 complaints. One complaint can name more than one area. Tap an area for its complaints and recalls.
2016 Subaru Outback recalls 4
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
Do not drive
- The problem
- Subaru of America, Inc. (Subaru) is recalling certain model year 2016-2017 Legacy and Outback vehicles manufactured February 29, 2016, to May 6, 2016. The steering column on the affected vehicles may have been improperly machined, and as a result, turning the steering wheel may have no effect on the direction of the wheels.
- The risk
- The loss of steering ability would increase the risk of a crash.
- The fix
- Subaru will notify owners, and dealers will inspect the lot number on the steering column, replacing the steering column, as necessary, free of charge. The recall began May 13, 2016. Owners may contact Subaru customer service at 1-800-782-2783 or by visiting http://www.wtd65.service-campaign.com. Subaru's number for this recall is WTD-65. Note: Until the vehicles have been inspected, owners are advised not to drive their vehicles.
- The problem
- Subaru of America, Inc. (Subaru) is recalling certain model year 2016 Legacy vehicles manufactured October 24, 2015, to November 16, 2015, and Outback vehicles manufactured October 24, 2015, to November 17, 2015. Due to the improper tightening of the securing nuts, the drive shaft may separate from the rear differential.
- The risk
- If the drive shaft detaches from the rear differential, it may strike the fuel tank and result in a fuel leak, increasing the risk of a fire.
- The fix
- Subaru has notified owners, and dealers will inspect the fastening nuts, and tighten or replace them, as necessary, free of charge. The recall began on December 10, 2015. Owners may contact Subaru customer service at 1-856-488-8500. Subaru's number for this recall is WQV-57.
- The problem
- Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Subaru Legacy 4-Door and Outback vehicles manufactured July 3, 2015, to July 27, 2015. Transmission oil may leak from a deformed seal cap on the propeller shaft yoke.
- The risk
- If the transmission oil leaks onto the exhaust pipe, there is a possible risk of fire.
- The fix
- Subaru will notify owners, and dealers will replace the propeller shaft, free of charge. The recall began on August 28, 2015. Owners may contact 1-800-782-2783. Subaru's number for this recall is WQU-56.
What owners say
Be the first Outback owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
643 complaints about the 2016 Subaru Outback
Newest first, as filed with NHTSA by owners. Page 1 of 26.
I am submitting this complaint concerning a failure of the front exhaust assembly on my 2016 Subaru Outback 2.5L. the dealership diagnosed a leak at the exhaust bellows in the front exhaust assembly and recommended replacing the assembly. I proceeded with the repair at a cost exceeding $3,000. I subsequently learned of Subaru Service Campaign WUJ-95, which addresses cracking of the bellows in the front exhaust pipe, including the catalytic converter, on certain 2015-2016 Subaru Legacy and Outback 2.5L vehicles. ...
Read the full complaint
Subaru has informed me that my vehicle's VIN is not included in the campaign. However, the component and type of failure described in the campaign appear relevant to the failure experienced by my vehicle. I contacted Subaru of America Customer Advocacy and requested an explanation of the technical distinction between the condition addressed by WUJ-95 and the failure diagnosed in my vehicle. Subaru declined to compare the conditions and denied my request for goodwill assistance or reimbursement. The company considers its review complete. I recognize that my vehicle's failure does not automatically establish that it qualifies for the existing campaign. However, I am concerned that a similar failure of the front exhaust bellows occurred in a vehicle of the same model year and engine type. I respectfully request that NHTSA review this report in conjunction with other complaints and available technical information to determine whether the failure warrants further examination, including whether it may affect emissions performance or present other safety concerns.
Odometer Fraud. The contact purchased a 2016 Subaru Outback. The contact stated that after purchasing the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale, but the contact discovered the seller was associated with a car dealer. At the time of purchase, the vehicle mileage was 87,059. After obtaining a Carfax report, the contact became aware that the mileage was 207,000.
The car accelerates on its own at times. I am not pressing the gas or going down a hill. It is flat road, sometimes even pulling into my driveway. There is also feeling like I am being bumped from the back and moving when I am idle. I am strict about oil changes and have it fully inspected when I take it every 3 months as I am a single mom and cannot afford for my children and I to be hurt in an accident or be without a car.
UNKNOWN When pulling into a parking space at the [[redacted]] diner my 2016 OUTBACK suddenly accelerated while I was ready to shift from drive to park. It was as if I put the gas peddle to the floor. There was a car about 6feet in front of me which I hit. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
There is a crack in the exhaust manifold and the exhaust smell is entering the cabin affecting driver and passengers' health. The problem has been confirmed by a Subaru dealer and an independent mechanic. There were no warning lights, I was made aware after routine maintenance by an independent mechanic. The same part has failed in multiple Subaru models: Recall WUJ-95 (SOA says my car is not covered in the recall/campaign due to my car's production date being 24 days after the "Affected Production Dates") ....
Read the full complaint
Additionally, Subaru of America extended the exhaust pipe warranty on the same part on other models, as late as 2018, so the part continued to be in use and problematic. Subaru of America says replacing the part is not covered by a recall for my car, however I feel strongly that it SOA should replace the part due to the proximity of my production date and the continued issues with the part across multiple models.
The reporting citizen was driving legally on [[redacted]] going forward towards the parking lot next to the round about when an uncrewed, autonomous commercial vehicle operated by Waymo suffered a catastrophic software/hardware failure. The 6,000-pound driverless robot taxi aggressively pursued and chased the citizen's vehicle in reverse for that full city block despite honking the horn and then holding it down the entire time as the killing 6,000 lbs robot car kept reversing towards the citizens car instead of...
Read the full complaint
going forward, forcing the citizen out into a perpendicular intersecting road onto [[redacted]] The citizen safely evaded a severe collision solely through high-speed defensive driving, reversing, and holding down the horn to warn surrounding motorists of the out-of-control vehicle. The autonomous system failed to stop, recognize the citizen's vehicle, or register the horn. Upon reviewing the internal vehicle data and footage, Waymo's corporate office confirmed to the citizen on several calls after the [[redacted]] reporting that this specific vehicle "went rogue." Waymo admitted the failure was severe enough that they immediately pulled the specific vehicle out of operational service. I have several case #s from Waymo of each call admitting fault. These 6000 lbs killing car robots are NOT SAFE and should not be allowed on public roads where real humans are driving! I can't sleep since [[redacted]] due to the nightmares of these killing car robots trying to kill me. I must factor in extra time to go anywhere as I cannot have these killing car robots near me and they are everywhere in my area. I visibly shake and sweat involuntarily whenever I see one of these even from very far away or even think about them - which is pretty much always now since [[redacted]]. Because Waymo deployed a malfunctioning 6,000-pound autonomous vehicle that aggressively chased a resident on public streets, this is an immediate Public Safety Hazard and Reckless Endangerment issue caused by Waymo. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
While driving the 2016 Subaru Outback, the vehicle experienced a sudden, catastrophic failure of the Continuously Variable Transmission (CVT). The transmission completely failed, resulting in an immediate and dangerous loss of propulsion while operating the vehicle. This created an immediate safety hazard for myself, my toddler and other drivers on the road, as the vehicle could no longer maintain speed or accelerate safely to clear traffic. A certified repair facility diagnosed the issue as a complete internal...
Read the full complaint
mechanical failure of the transmission, requiring a total replacement at an estimated cost of roughly $11,000. This generation of Subaru CVTs has a well-documented history of premature, catastrophic mechanical failure, which Subaru of America has previously acknowledged via past warranty extensions. The sudden loss of power caused by this engineering defect poses a severe and ongoing safety risk to consumers. [[redacted]] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
SUBJECT: Formal Safety Defect Complaint: 2016 Subaru Outback - Manufacturing Nondisclosure of Latent "Day 1" Design Flaw Causing Ignition Key Entrapment, Uncommanded Steering Column Lockout, and Severe Family Safety Risk I am writing to formally report a severe, unaddressed safety defect and a deceptive corporate practice by Subaru of America, Inc. affecting my 2016 Subaru Outback. This vehicle suffers from a "Day 1" latent engineering flaw that causes the physical ignition key to become permanently trapped in the...
Read the full complaint
ignition cylinder, triggering an uncommanded, rigid locking of the steering column assembly. Subaru has possessed documented knowledge of this failure for years, cataloging it under Technical Service Bulletin TSB 16-112-18R. Rather than fulfilling its statutory obligation to issue a comprehensive federal safety recall, Subaru deployed a voluntary, time-bound 8-year warranty extension. Subaru conveniently did not notify me of this warranty extension. By doing so, the manufacturer unconscionably ignored this defect, placing its customers at direct peril. They capitalized on asymmetric information to shift both the financial burden and the severe physical safety risks of a known factory flaw onto my family, the moment an arbitrary time threshold expired. My family and I have been at active, continuous risk in this vehicle since the day we purchased it due to an engineering error that was present when the car rolled off the assembly line. The root cause of this failure is a fundamental engineering defect within the Continuously Variable Transmission (CVT) shifter assembly, specifically, the premature degradation of the electrical contacts within the select lever park-range switch.
Vehicle: 2016 Subaru Outback Recall Number: WUJ95 - Front Exhaust Pipe Bellows Crack I incurred repair expenses to address a condition that was later covered by Subaru Recall WUJ95. At the time of the repair, I was unaware that the vehicle was subject to this recall because I never received any recall notification from Subaru. The affected component was the front exhaust pipe bellows assembly covered by Recall WUJ95. The repair was completed by an independent repair facility. The condition involved a cracked...
Read the full complaint
exhaust bellows assembly. The failure of this component allowed exhaust gases to escape from the exhaust system into the cabin and is the condition identified by Subaru in Recall WUJ95. The issue was diagnosed and repaired by an independent repair facility. The repair addressed the same component and condition that was subsequently identified by Subaru as part of Recall WUJ95. After learning of the recall, I contacted Subaru of America seeking reimbursement because the repair was completed after the recall had been issued. Subaru denied reimbursement and stated that repairs performed at third-party facilities are not eligible. During the reimbursement review process, I requested documentation showing when and how recall notification was sent to me, including the address used, mailing date, and method of notification. Subaru declined to provide this information. Subaru also declined to provide the specific guidelines relied upon in denying reimbursement. My concern is that I never received recall notification before obtaining the repair, which prevented me from having the recall performed through an authorized Subaru retailer. I am requesting that NHTSA review whether recall notification requirements were properly satisfied in this case and whether vehicle owners are being provided sufficient information to verify recall notification when reimbursement requests are denied.
On 05/08/2026 the brakes failed while in a queue at a drive-up restaurant. The car was steered away to a flat part of the parking lot. After a restart the brakes returned to operation and the car was taken to the dealership where the brake line were flushed and the brake fluid replaced. On 05/25/2026 the brakes failed after backing out of an inclined parking space in a parking garage. The car came to a stop when it backed into a concrete wall. The car was towed to the dealer. The dealer inspected inspected the car and reported that the brakes were working as they should.
Parasitic battery drain due to a faulty DCM module. I've purchase 3 batteries in the past 16 months. I now have to keep a trickle charger on my car at night to ensure my battery is not dead in the morning. Unable to park overnight without charger due to fear of another dead battery.
The DCM (Data Communication Module), also referred to as the Starlink telematics module, has failed. This failure is causing a continuous parasitic battery drain, which rapidly depletes the vehicle's battery even after charging or replacement. The component remains installed in the vehicle and is available for inspection upon request. The failure has resulted in repeated battery drain and loss of vehicle operability. I have experienced a dead battery approximately 4-6 times between September 2025 and present, and...
Read the full complaint
the condition has worsened to the point where the vehicle cannot remain running or operable without the battery dying within approximately 5 minutes. This creates a safety risk because the vehicle can become inoperable without warning, increasing the likelihood of being stranded in unsafe conditions or unable to use the vehicle in an emergency. Yes, the issue has been diagnosed and confirmed by a Subaru dealership, which identified the DCM module as failed and requiring replacement. The failure is consistent with a parasitic battery drain caused by the DCM. The vehicle has been inspected by an authorized Subaru dealership.I have also contacted Subaru of America and opened a case requesting assistance with the repair. The primary symptom was repeated battery drain and failure to start beginning around September 2025. The issue progressed over time, with multiple instances of a dead battery, and has now worsened to the point where the battery drains within minutes, preventing normal vehicle operation. There were no consistent warning lights directly identifying the DCM as the cause prior to diagnosis.
leak in cam carrier gasket caused large ammounts of smoke to fill engine bay and enter cabin air system. Struggled to breath and vision to an extent was obstructed. when car was parked, smoke continued to fill the engine bay. problem was confirmed by an independent technitian, with the vehicle undergoing a complete inspection about a year ago from the dealership of purchase. no warning lamps turned on until enough oil had seeped from the leak in the liquid silicon gasket, at which point the low oil warning light had turned on.
My 2016 Subaru Outback CVT transmission has exhibited an intermittent jerking and grabbing sensation when accelerating from a stop, worse when cold, since at least February 2023. This is a known defect covered under Subaru warranty extension bulletin 16-115-18. February 2023 - An authorized Subaru dealer documented the complaint in writing. The technician stated the vehicle never warmed up during the test drive and dismissed the concern. The CVT issue was never repaired. I was never informed of Subaru's CVT...
Read the full complaint
warranty extension program. February 17 2026 - seven days before my warranty expiration - the same authorized Subaru dealer physically identified and documented a CVT oil pump cover leak. The same jerking complaint was again documented in writing. No repairs were made and the warranty expired one week later. The CVT defect has been physically confirmed by an authorized Subaru dealer within the warranty period and Subaru of America has denied my warranty claim in writing. This issue presents a safety concern. The unpredictable jerking and hesitation when accelerating from a stop creates dangerous situations in traffic, particularly at intersections and when merging. The vehicle is available for inspection upon request. Subaru chose to handle this known widespread defect as a quiet warranty extension rather than a mandatory recall despite hundreds of owners reporting identical symptoms.
My 2016 Outback 2.5L model experienced an exhaust noise and/or odor coming from cracks at the bellows section of the front exhaust pipe which includes the catalytic converter. It was diagnosed as leak occurring at the front exhaust pipe. Quoted repair for replacement part only is $2700 plus $1000 labor to repair. Upon investigation, it was discovered that Subaru Recall WUJ-95 with subject Exhaust Pipe Front (EPF) Bellows Cracking was issued in 2020. My specific VIN was excluded from this recall but I have...
Read the full complaint
experienced the exact issue described in the recall. As a result of this situation and exhaust inhalation the car is not able to be driven, this cause breathing issues for me, my wife and our 9 month old baby.
Brake light comes on while driving and power steering also locks up..
Almost after I took ownership of my vehicle in August 2024 from Lexus of Pembroke Pines, I noticed a light on the dashboard that would light intermittently. I purchased an extended warranty for almost four thousand dollars at the time of sale, thank God, as this car has needed a lot of work that I was never told about nor was anything in the CARFAX indicating so many issues. Subaru of Pembroke Pines service department took vehicle in to work on the air bag sensor as that is what seemed to be the issue. In the...
Read the full complaint
sixteen months that I have been paying off a loan, the car has been in service for at least a combined ten months plus. They have changed the sensor twice and have changed the harness twice to no avail and that has been covered by the warranty. Now Subaru wants to take apart the car to trace wires to try to find out why the light still won't go out. The warranty company is refusing to take responsibility for the payment for the work and I cannot and will not pay out of my pocket. Subaru wants me to take my car back and drive it. I DO NOT WANT TO DIE FROM A FAULTY AIRBAG. There is something grossly wrong with the vehicle, the service department and especially the warranty company. Please help me get my vehicle fixed without having to be further raped financially. Subaru is trying to get me to purchase yet another vehicle AND I was told by the service lane manager that I should never have been sold that car. IT IS DANGEROUS. My files you are requesting are in my car which is at the dealership.
I purchased a replacement battery in 2023. In August of 2025, the battery died, requiring a jump start. A local auto parts store checked the battery and it tested within acceptable limits, showing around 513 amps. A private shop confirmed this, and cleaned the battery terminals and cables. The battery functioned well until around November 2025, when it again died requiring a jump start. The battery again died in December 2025, about one month later, requiring a jump start.
1.Windshield crack in the deicing area. Driving on a highway heard a loud boom as if a very big rock hit the car. 30-40 second later there was another boom of normal loudness. At this moment windshield crack has been noticed. The windshield will not be available, replacing it on 12/22/2025 2. Visibility has been affected 3. No, problem was not reproduced. Dealer representative said that the problem is not covered by Subaru. 4. Windshield was visually inspected by the dealership representative. I will try to...
Read the full complaint
collect more data at the windshield replacement shop. 5. There were no symptoms of the problem. N.B - the crack outside is flat, as if no rock hit happened. - I have camera's MP4, where sounds can be heard, 1GB
The contact owns a 2016 Subaru Outback. The contact stated that the horn was inoperable. The vehicle was taken to the local dealer for a routine recall repair, and it was diagnosed and determined that the steering roll connector/clock spring had short-circuited. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.
Steering wheel controls frequently fail to work properly on the cruise control system specially the speed control. Also the exhaust system bellow has cracked. The moonroof leaks into the cabin and floor area of the passenger side. Also leaking into the A pillar on the passenger side. I only have a picture of the engine valve cover that is leaking and had to be replaced. I have video of the exhaust leak coming from the crack in the bellow pipe. Do not have video of the cruise control speed issues as I can't take a video while driving.
I had a rock thrown at my vehicle's windshield and required a replacement. I went to a Subaru dealership, Zeigler Subaru of Kenosha, local to me for a replacement. A day after I received my car, the windshield developed a hairline crack emanating from the bottom. I brought it back to the dealer and they replaced it again. After that time, it was a whole week and a half when I noticed a hairline crack, this time from the top working its way down. I brought it once again to the dealer for a replacement and a better...
Read the full complaint
explanation as to what is going on. 1.5 months later, I took my car again and was good for a little over a month, when I noticed the same hairline crack, this time from the bottom. I am up to having three windshields being installed and have no confidence in the safety and longevity of the vehicle I have. Subaru has had engineers come out to evaluate my vehicle and determined that its structural construction is not compromised and have tried to diagnose another probable cause coming from the windshield wiper heater and unplugged it. I have heard crack noises when driving at random intervals and have it noted to the dealership. no further update has been told to me as of the writing of this concern.
Catalytic converter is cracked. This is confirmed by an independent service center. Apparently there is a recall for this issue for 2015 and 2016 Subaru Outbacks manufactured up until September 2015. My 2016 Subaru Outback has the same issue and was manufactured in April 2016. The recall should include all 2016 Subaru Outbacks, not just those manufactured in 2015.
Accelerated on its own doing 25mph and accelerated quickly and took pumping brakes to get it to stop
I reached under the steering well to the foot well because it seemed that my AC was not putting out any air. I touched something and received a burn on my hand. I reached out to the SOA but was told to take it to the dealer. Then they asked me to call back and discuss further. When I called back I was told to take it to the dealer. I'm not sure I want to take it to the dealer to be charged a diagnosis fee. It seems the "kick panel" should cover this hot part to not allow access.
Subaru Outback: every year compared
| Year | Complaints | Recalls | Grade |
|---|---|---|---|
| 2020 | 906 | 6 | F |
| 2019 | 1,036 | 3 | F |
| 2018 | 816 | 3 | F |
| 2017 | 921 | 4 | F |
| 2016 | 643 | 4 | F |
| 2015 | 509 | 5 | D |
| 2014 | 208 | 10 | C |
| 2013 | 297 | 12 | D |
| 2012 | 295 | 16 | C |
2016 Subaru Outback vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2016 Subaru Outback | 643 | 4 | F | |
| 2016 Ford Explorer | 2,466 | 15 | F | Compare |
| 2016 Kia Sorento | 1,263 | 8 | F | Compare |
| 2016 Ford Edge | 932 | 7 | C | Compare |
| 2016 Jeep Grand Cherokee | 313 | 9 | A | Compare |
| 2016 Hyundai Santa FE | 238 | 3 | B | Compare |
| 2016 GMC Acadia | 236 | 4 | C | Compare |
| 2016 Dodge Durango | 161 | 3 | B | Compare |
| 2016 Buick Enclave | 142 | 4 | C | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2016 Subaru Outback
Does the 2016 Subaru Outback have any recalls?
Yes - NHTSA lists 4 recalls for the 2016 Subaru Outback: air bag / restraint control module (December 2019); column (May 2016); driveshaft (November 2015); driveshaft (August 2015). Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
What are the most common problems with the 2016 Subaru Outback?
By the complaints owners filed with NHTSA, the most common problem areas are the electrical system (309), visibility & wipers (91), engine & cooling (55).
How many complaints has the 2016 Subaru Outback had?
643 complaints have been filed with NHTSA, the first on August 31, 2015 and the latest on November 2, 2026. Of these, 22 describe a crash and 3 a fire, and together they report 13 injuries and 0 deaths.
Is the 2016 Subaru Outback a reliable vehicle?
Its Safety Index is 22 out of 100 (grade F: far more problems than a typical Subaru Outback year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which Subaru Outback years have the most complaints?
2019 (1,036), 2017 (921), 2020 (906). See every Subaru Outback year compared.
What should I do if my 2016 Subaru Outback has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data