2018 Ford Explorer Electrical problems

The contact owned a 2018 Ford Explorer. The contact stated that while driving at various speeds, a message displayed on several occasions instructing the driver to pull over and shut off the vehicle because the battery would shut off. Upon pulling over and turning off the vehicle, the vehicle failed to restart and required towing on several occasions. The vehicle was towed to the dealer, where a wiring failure was determined. The dealer attempted to repair the vehicle, but the failure persisted. While driving...

The driver side Keyless door entry pillar has come off on the highway and hit something. The keyless door entry panel came off in 2023 and Koons Ford of Annapolis charged me $ 523.00 to fix the panel. The panel has a small clip and double stick tape. Sorry, double stick tape is not going to hold up to weather variations throughout the year, wind speed and age. Terrible and dangerous design. You gave 2017 a Recall 25S53 for ford but NOT 2018

The horn on my vehicle activates (blows) when I turn the steering wheel to certain positions. I believe this to be a road hazard. Especially since I had to remove the horn relay to prevent the horn from blowing in traffic until I can get it repaired. Several other Ford vehicles have been recalled for this exact problem. Just to diagnose this problem at the Ford dealer is $170.00. Help!

Total engine failure in the Ford Explorer XLT 2.3L ecoboost.

Entertainment system control. Power draws down and kills battery. Display locks into reverse camera, and I can't access any controls for extended periods of time. Display just locks, and I can't adjust anything in it. This seems to be a known issue for all Sync 3 based backends.

I am filing a safety complaint regarding unresolved recalls on my 2018 Ford Explorer (VIN: [[redacted]] ). FIRST RECALL: Over two years ago, I was notified to repair the exterior A-pillar trim/window shields. The dealer in Yakima, WA, placed me on a waiting list and said the part was unavailable. I have been waiting over two years with no resolution. Recently, while driving on the highway, this part fell off and struck the windshield of another vehicle behind me, creating a dangerous situation and potential for...

During a storm, our SUV had water leaking in through the top, middle of the windshield. The water soaked the dashboard controls and our heating/air system was stuck on high heat and would not turn off. It was 70° and it was extremely hot in the SUV and the windows kept fogging up making it hard to see. Our temperature controls no longer work properly.

Purchased 5 years ago aprox 100k miles.kept oil changed regularly. Of course parts kept coming off, monk safety clips etc. It's a dime store matcbox wannabe. Then the abs and engine light came on. The computer was acting up and it would do crazy things. Lock and unlock, go into that slow drive as i was pulling into a road. Etc. These would self correct, all but the abs in a matter of minutes. Oh i did have it checked. All that came up was right wheel speed sensor. I paid to have it fixed. Ford dealer told me his...

Both driver and passenger low beam headlights started strobe, than completely stopped working while driving at night. This was extremely stressful and dangerous as I was no longer able to see the roads very well, my options were get a tow truck to pick up and bring my vehicle from Michigan back to Minnesota or sit on the side of the road until the morning also a safety risk. Upon inspection the following day, it was only the low beam that was not working and all other LED's were working. This is when I tried to...

Fault code B14E7:08-0A Right Front Enhanced Exterior Lighting System, passenger headlamp will not turn off until BCM disconnects after 20 minutes. Dealer diagnosis determined a possible headlamp control module FB5Z13C788D fault (replaced left module with right module and same headlamp stayed on so both headlamp control modules are correctly functioning) this indicates a broken wire in right front enhanced exterior lighting system wiring harness. Problem remains unresolved.

Traveling 50mph, noticed smoke rolling from under the dash. Got to the side of the road. The entire dash was engulfed in fire. I had to fight my way out of the car after the doors locked. After I got out of the vehicle I called 911. Fire department came. It has been ruled as electrical. I am not sure whom I need to reach out to yet in regards to this matter and a total loss.

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, the engine overheated, and the vehicle stalled. The contact inspected the vehicle and discovered that the serpentine belt had failed. The contact replaced the serpentine belt, and the vehicle was repaired. Later, while operating the vehicle, several electrical warning lights were displayed. The battery was replaced, but the failure persisted. The contact replaced the alternator; however, after replacing the alternator, the...

I previously reported a battery 'explosion' in this 2018 Ford Explorer with ODI 11678705 due to my concern for a potentially highly dangerous situation for my grandchildren who were riding with me. And myself. An unpleasant smell intermittently followed this car that morning July 10 Upon opening the hood it was evident that battery acid had leaked out of the battery and 'exploded' covering most visible engine parts. Entire time of drive there was no 'alert' showing up on my dashboard July 11 car would not start to...

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, there was an abnormal acidic odor inside the cabin of the vehicle. Upon raising the hood and inspecting the vehicle, the contact became aware that the battery cap was unsecured, and the battery acid had covered the interior of the engine compartment. The vehicle was towed to the local dealer, where the engine compartment was cleaned, and the battery was replaced. The vehicle was repaired. The contact stated that the battery was previously replaced at a different dealer. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 73,000.

Screen blacks out and unable to connect handsfree, control rear ac or anything else that requires use of screen

The radio flickers on & off when started for about 10 minutes. It's very distracting. The windshield makes a whistling noise when going above 50mph

The contact owns a 2018 Ford Explorer. The contact stated that while attempting to start the vehicle, there was an abnormal clicking sound coming from the vehicle and the vehicle failed to start. The contact stated that the clicking sound was the doors locking and unlocking continuously. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the keyless entry keypad on the driver's side door, resulting in battery drainage. The contact was informed that the keypad...

I was pulling into my apartment division I heard a loud pop and the vehicle then died. I tried starting it back up and it then caught on fire. My door locks were stuck in the locked position and I could not get them to unlock. Within a few seconds (which felt like several minutes) the doors did unlock and I was able to get out. There were no warning lights or messages prior to this. Fire department did arrive and put out the fire. The car was a total loss. Report has been filed with insurance company. I...

The contact owns a 2018 Ford Explorer. The contact stated while driving approximately 35 MPH, there was black smoke coming from under the hood. The vehicle was towed to the local dealer, who diagnosed that the battery was faulty. The battery was replaced. The contact stated that while driving, there was black smoke coming from under the hood, and the vehicle was towed to the dealer and was diagnosed with transmission failure. The transmission was replaced. Later, while driving again, the black smoke was again...

The High-Speed Cooling Fan Motor Relay (Recall 21N01) and the Exterior A-Pillar Apical Molding (Recall 24V031) failed on my vehicle. The cooling fan caused the engine to overheat repeatedly, and the vehicle became undrivable. Unfortunately, I no longer have the vehicle, as it was surrendered to my bank and later sold at auction. However, service records, diagnostic reports, and recall information are available upon request. The overheating engine presented a significant safety risk while driving, as it could have...

The vehicle experienced multiple defects, including: Overheating due to a malfunctioning cooling fan motor relay. Exterior A-pillar trim detachment. Persistent starting issues, even after replacing the battery. The vehicle is no longer in my possession due to repossession, so inspection may not be possible. How was your safety or the safety of others put at risk? The overheating issue posed a risk of engine failure while driving. The detached A-pillar trim could have caused a road hazard for other drivers if it...

This will be another submission as I am getting frustrated. My Explorer has had constant issues like clock work every 6/7 months. I have gone through 6 batteries in a two year time span. I have had the battery control module replaced because I thought that would be the fix. However it is not. While operating my vehicle yesterday on [[redacted]] after barely even starting the battery died and my car said multiple systems were failing almost causing someone to rear ended me. This is a safety issue like no other. When will I receive feedback for these matters I keep submitting? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Radio and back up screen stop working 1 month after purchase.

The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact noticed that water was leaking in on both sides of the windshield. The contact stated that due to the failure, rainwater was leaking onto instrument panel, causing the instrument panel to become inoperable. The contact stated that the air bag warning light was also illuminated. The vehicle was taken to the dealer and the dealer confirmed the failure. The contact was informed that the vehicle was not included...

The APIM (sync module) went blank. It controls backup camera, radio, heat and air, sensors on the bumper etc... Ford said the APIM failed testing and recommended to replace the APIM to gain access to the screen. It would only cost about $1100. This is a safety issue because the sensors will not work.