2019 Ram 2500 Engine problems

Premature lifter and cam failures on the 6.7 engines. Yes it can be inspected. Yes it was heard and confirmed by multiple dealers and sources. It can be an issue if the engine locks up when driving

The truck acts like it running out of fuel when entering the hiway. One time it just died and restarted. Then several days later when pulling out onto the hiway the same thing happens. Last time was May 6. Acts like it's running out of fuel. Keep pumping the petal and it takes off.

The contact owns a 2019 Ram 2500. The contact stated that while driving at an undisclosed speed, there was an abnormal burning odor inside the vehicle. The contact assumed that the odor was coming from the AC and turned off the AC. No warning light was illuminated. The contact parked and turned off the vehicle at the residence. Later that night, the contact heard a loud bang coming from the vehicle. The next morning, the contact and her friend looked under the hood and discovered that the fuse box, harness, and...

Poor quality hydraulic roller lifer arm failure caused a frown rod and a hole in the engine block

The contact owns a 2019 Ram 2500. The contact stated that while driving at 50 MPH, there was blue and white smoke coming from the engine compartment. The vehicle was taken back to the residence. The contact saw a cloud of smoke coming from the engine compartment. The contact waited to see where the smoke was coming from and attempted to start however, the vehicle failed to start. The vehicle was then towed to an independent mechanic, where it was diagnosed, and it was determined that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and filed a complaint. The failure mileage was 110,000.

I have experienced unexpected loss of power during acceleration, lack of exhaust breaking and engine codes p003a and p006f which I believe are associated with the turbo actuator.

Leaking anti freeze from back of motor

On June 26, 2024 during a long road trip, the vehicle lost power repeatedly in the middle of an area with no road service. It put my safety and that of my passenger at risk on the highway as losing power suddenly causes danger in fast-moving traffic causing the risk of potential collisions with other vehicles. There was no warning lamp indicating the failure would occur. To this date, the dealer has not fixed the issue. After approximately three weeks, I picked up the vehicle after it as allegedly repaired (at that...

Initially I witnessed a large volume of smoke coming from the exhaust pipe when pulling up to fuel pump. A passer-by informed me that there were flames underneath the truck on the passenger side. I then got out of truck, stooped down to look underneath, and observed a hose leading from the exhaust system on fire and multiple exhaust components glowing red hot. After getting my passenger out of the truck I got back in, put it in drive and pulled forward away from the fuel pumps and made it about forty feet before...

Air intake grid heater bolt deteriorated, falls into the intake runner and gravity causes the bolt to end up in cylinder #6 creating severe damage to piston, valve and head damage causing expensive repair or a total long block repair on the 6.7 Cummins engine.

My truck began idling hard and stalling out. I've contacted the local dealership multiple times to have the recall fixed for the CP4 fuel pump replaced and software updated and keep getting told they don't have the parts. I'm now having to schedule to have the truck looked at out of my pocket.

I've been waiting for a recall fix for the Y78 on my Ram Cummins. My dealer keeps saying they only get in a couple of the high pressure fuel pumps every few weeks. I've started the process back in December with no estimated wait time other than it will be many months before they fix it. I know many people who have but a direct replacement pump that will remedy the problem and have been reimbursed for parts and labor. My really helpful dealer this morning told me to contact NHTSA and file a complaint about how to go about the reimbursement process to get it fixed myself or provide me other options to get it fixed. Any help would be appreciated.

March 10,2023 2019 Ram 2500 Cummins 6.7L Diesel I picked up my truck from the dealership this morning, after they did the outstanding CP4 fuel pump recall. I drove the vehicle home (approx 20) miles. Parked the car in the driveway for about 3 hours. Then took a short trip to the store. After the store, when leaving the parking lot I noticed an electrical/plastic smell. Within in seconds smoke started to come through the air vents. I pulled the truck over, turned off the truck, open the hood when fire...

I have been having issues starting my truck when I took it in they said it was an ecu reflags needed. I believe it is an open recall y78 for over a year and they do not have the part. But my truck all of a sudden loss power on the freeway doing 65 my wife and daughter started crying I barely made it to the edge of the freeway with being hit within inches of a semi truck. We sat on the side of the freeway with trucks passing us shaking our truck from the wind. Finally I had to call Chp to have cars slow down when it...

Smoke emanated from the engine bay shortly after starting the vehicle first thing in the morning. The temperature outside was less 40*. Shortly after seeing smoke, the engine bay was engulfed in flames, centered on the hood, near the windshield. Newer vehicles have fire risk recalls regarding the intake-grid heater shorting out, but not the 2019 model. The grid heater would have been on due to the temperature. Please see the reports from the Police and Fire Department attached. The truck was totaled.

UNKNOWN. Truck will not start. Clicks, all warning lights come on, clicks, and nothing. Recall not performed as dealership states if they do the recall it will cause a complete engine failure.

Issue with high pressure fuel pump and loss of turbo boost. At first Mopar/ Dodge refused to replace the fuel pump regardless of the recall. After hours on the phone they finally agreed to replace fuel pump but said no idea why turbo isn't working correctly.

As I was pulling out of the parking to to merge with traffic, the truck lost all lost all response to the accelerator pedal midway into merging with on coming traffic. I was able to get the truck into the turn lane to avid being hit by traffic. as the truck costed to a stop the dash indicated that the to see dealer for exhaust system service.

I was driving home from the market and the truck slowed down to 16 mph. I could not go any faster. I pulled over to the middle of the street and turned the truck off for a minute. I then restarted it and attempted to drive it somewhere safe. The truck finally came to a stop right before an intersection. I had to get out because cars were coming fast. I was afraid someone was going to hit me. I called AAA right away. They told me the tow truck was on the way and that they would send the police. The police never...

Engine started to slip or misfire. Became worse and then light came on saying Exhaust Emission Service was needed. The truck lost power as it limped to the side of the road. The Service Electronic Ignition light then came on and truck turned off. Would not crank again.

In August 2020, while I was driving my vehicle at approximately 15 mph, with approximately 13,500 miles on the odometer, I noticed that the vehicle's transmission gauge was about 230-240 degrees. I pulled over and smelled smoke. Luckily, my passengers and I were able to get out of the vehicle. The vehicle was completely destroyed. I have video showing flames coming out of the passenger side engine compartment. I had previously taken my vehicle in for repair for recall W03 to have the transmission valve body...

The contact owns a 2019 Ram 2500. The contact stated that while driving approximately 25 MPH, the engine started to knock. The contact took the vehicle to the dealer who diagnosed that the fuel injector pump had blown out and caused other damage to the engine. The engine needed to be replaced. The vehicle had not been repaired. The manufacturer was aware of the issue and opened a case. The approximate failure mileage was 48,000.

I started my pickup and pulled out of garage put in park to close my garage door and with 2-3 minutes at idle, smoke was coming into the cab, got out of vehicle and opened hood and found flames coming from fuel injection pump area, was able to get fire out before it burnt the truck completely.

Truck making ticking noise from engine from fuel pressure pump cp4?? Makes noise at idle and when in motion sometimes jerks and stalls

I just purchased a used 2019 ram on day two check engine light comes on loss of power while driving at highway speed. Dealer is telling me it is codep0299 they checked and cleared code. Now 12/18/ back with dealer for same code p0299 and loss of power or going 8nto limp mode.