Subaru Outback Suspension problems by year

an improperly loaded trailer. I was forced to countersteer aggressively multiple times to regain control. The rear continued oscillating through several corrections before the vehicle finally stabilized. I have extensive experience driving different vehicles, including trucks, SUVs, and performance cars. I have never experienced this degree of instability from a modern vehicle during a comparable maneuver. I believe a less experienced driver could have lost control entirely, potentially resulting in a serious or fatal crash. Afterward, I discovered reports from other 2026 Subaru Outback owners describing similar rear-end instability, swaying, and fishtailing at highway speeds, particularly in windy conditions. I am concerned that the redesigned Outback may have a handling or directional-stability issue that warrants further investigation. IMPORTANT VEHICLE IDENTIFICATION NOTE: This was a dealership loaner, not my personal vehicle. The VIN associated with this report is a possible match identified through dealership inventory, but I cannot confirm that it belongs to the exact vehicle I drove. The correct VIN should be verified through Subaru of Port Richey's loaner records.

rack, and lower control arms. Severe corrosion and rot in this area create an imminent risk of structural failure, specifically the potential separation of the lower control arms while driving. Such a failure directly impacts steering stability and vehicle tracking, creating a catastrophic hazard that could result in a sudden loss of vehicle control, an inability to steer, and an increased risk of a severe motor vehicle accident. The dealership has issued an itemized repair estimate of $2,900.00 to replace the structurally compromised subframe assembly.

rusted out area. The attached photos are the same ones I submitted to subaru of America. They offered no help or discount on the parts. I bought a new subframe from subaru and when I picked it up the parts guy said this is very common and that it's half his sales is subframes.

I have expressed this concern multiple time to multiple reps from Autozone over the last 12 years. Autozone's remedy was simply to change the color and part number, then continue selling the same sub standard part. Your attention to this would be beneficial to all involved. Thank you.

lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback's which suggests that Subaru had knowledge of the defect. Since the incident several other premature "wear" defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

may pose a safety risk if the condition worsens or results in component failure. The vehicle has been inspected by an authorized dealer, who acknowledged the presence of similar suspension noise during evaluation; however, no corrective repair has been performed. The vehicle and all components remain available for inspection upon request.

that exceeds the manual recommendations including always flushing the underside of the chassis during washes; especially the winter season. The car was taken to a dealer to have the intake manifold gasket looked at. The dealer took the opportunity to raise the car in the air, conduct an inspection and reported that the front carriage assembly is rusting away and considered dangerous. The Service Manager indicated that the model years 2010 to 2014 exhibit a high-degree of corrosion to the supportive member which holds the engine and transmission in place and if it fails could cause an extremely dangerous situation. What if any information has NHTSA compiled regarding these issues and Subaru's use of an under-designed, defectively manufactured part that could potentially cause a serious accident if the support structure collapsed? And if the NHTSA has conducted any research into this issue is there any option for a consumer to recoup or require Subaru to cover the cost of replacement which according to two Subaru Dealers is approximately $4,200. Below is a recap of the repair costs including parts and labor: CRADLE FRM CP OBK 2-3 Day QT 1 $842.66 20202AJ04B ARM ASSY F RH In Stock QT 1$173.41 901000346 BOLT FLG 14X128 In Stock QT 2 $8.18 / $16.36 20420XA000 LINK AY F STABILIZER In Stock QT 2 $72.85 / $145.70 20202AJ05B ARM ASSY F LH In Stock QT 1 $173.41 901000060 BOLT FLANGE In Stock QT 2 $2.88 / $5.76 The labor is calculated at 13.5 Hours @ $189.00

they never disclose this problem. They basically told me it was my fault when I've had the car for two months that the frame is completely rotted. The car is clunking and not driving mechanically the way it should

Notably, my rear subframe does not have this issue. Evidence is available that this is exact issue is happening to many cars in this generation, found upon scanning forums such as reddit [[redacted]] and the subaruoutback.org owners forum [[redacted]] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

the brakes, check engine, power steering, and engine overheating warning lights were illuminated. The vehicle was taken to the dealer seven times; however, the dealer was unable to determine the cause of the failures. The contact stated that the dealer replaced the passenger's side rear wheel bearing. The manufacturer was not made aware of the failure. The failure mileage was 201,206.

bought & had been serviced and sold by this same dealer with only one owner It was in pristine condition, according to an independent mechanic that inspected it before I bought it. All my oil changes are done at the same dealer, yet the problem was not identified before. This is a vehicle made for off road travel (which I have NOT done) and for winter weather. WHY IS THE SUBFRAME rotting? Reedit reports that there are at least 200 others that have reported the same problem to you for cars of this same year! Please advise!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6