Check a vehicle VIN check Latest recalls Latest complaints Common problems Rankings Compare vehicles Recall roundups All makes Guides Share your experience
Theme

Electrical system

2004 Ford Excursion Electrical problems

Owners have filed 21 complaints about the 2004 Ford Excursion's electrical system with NHTSA - 22% of all its complaints, most recently on March 30, 2021. They describe 0 crashes, 2 fires and 0 injuries. Dead batteries, warning lights, wiring, alternators, infotainment and electronic module failures.

Complaints
21
Recalls
1
Crashes
0
Fires
2
Injuries
0
Deaths
0

Electrical recalls for the 2004 Ford Excursion

Electrical system: wiring

05V270000180,104 vehicles affected

The problem
Certain pickup trucks, sport utility vehicles and vans equipped with 6.0L diesel engines may experience stalling without warning while driving and may or may not restart.
The risk
Should the engine stall, a vehicle crash could occur.
The fix
Dealers will upgrade the fuel injection control module (ficm) wire harness or replaced, and/or have a new injection control pressure (icp)) sensor connector installed free of charge. The recall began on july 22, 2005. Owners may contact ford at 1-800-392-3673.

Electrical complaints

Electrical systemEngine & coolingFuel system

Total loss of engine power massive amount black soot exiting exhaust while driving recall # 05v270000 was not performed on vehicle ( I am the original owner) never received notice in mail and dealer somehow missed this "work" and ford should have followed through on this situation. Other repairs done to this vehicle to "fix" this problem was to drain the fuel tank (algae in fuel was the excuse-no algae) fuel pump and filter rail (not problem) two turbochargers were replaced due to excessive sooting (one warranty...

Read the full complaint

one at my expense) egr valves and a cam sensor (ford knows the problems exist because ford discountinued the 6.0 Litre motor) this problem has occured multiple times over my ownership.

Filed Incident Electrical system · Engine · Fuel / propulsion systemNHTSA 11405521
SteeringElectrical systemEngine & cooling

Tl* the contact owns a 2004 ford excursion. While driving, the vehicle stalled without warning. The contact placed the gear into neutral, while in traffic, and restarted the vehicle. Afterwards, the vehicle was able to drive normally. The vehicle was taken to future ford lincoln (located at 650 automall dr, roseville, ca 95661, (888) 656-7577) where a wiggle test was performed because a failure code could not be found. The injection control pressure was replaced with a used part. The contact stated that the vehicle...

Read the full complaint

was worse after the replacement of the used part and the steering wheel became difficult to steer. The vehicle was taken back to the same dealer who stated that a wire harness was needed to repair the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vin was not included in nhtsa campaign number: 05v270000 (electrical system). The approximate failure mileage was 59,000.

Filed Incident Steering · Electrical system · EngineNHTSA 11205210
Electrical system

Tl* the contact owns a 2004 ford excursion. The contact stated that the vehicle failed to restart. The contact referenced nhtsa campaign i.D. Number 05v270000 (electrical system) and called the manufacturer, who advised that the vin was not included in the recall. The failure mileage was 140,000.

Filed Incident Electrical systemNHTSA 10560375
Electrical systemAirbags

Tl* the contact owns a 2004 ford excursion. The contact stated that the horn would sound independently without the engine being powered on. The contact had to disconnect the fuse to stop the horn from sounding. The contact took the vehicle to a dealer, who stated that the horn, air bag and cruise control needed to be replaced. The dealer did not state why the horn would sound without it being engaged. The contact stated that the unit had been replaced previously but the repair did not remedy the issue. The failure mileage was 98,000.

Filed Incident Electrical system · Air bagsNHTSA 10522908
Electrical systemEngine & coolingFuel system

While driving the vehicle, it will go into a reduce power mode or sometimes stall. This has happened at various speeds, from around town to highway driving. Very dangerous condition when trying to make left turns and power is lost or engine stalls. Also engine fails to start or starts and stalls right away on occasion. Call ford customer relations and dealer and they tell me my vin is not covered under the recall. I am experiencing the same symptoms but I am not covered. Don't want to spend more money at dealer if they don't know what is happening and how to fix it. *Tr

Filed Incident Electrical system · Engine · Fuel / propulsion systemNHTSA 10501155
Electrical system

Tl*the contact owns a 2004 ford excursion. The contact was driving approximately 25 mph, the engine stalled without any warning lights illuminating on the instrument panel. The engine restarted momentarily and the vehicle resumed as normal. The vehicle was taken to an authorized dealer and diagnosed. The failure was related to the injection control sensor. There was a recall related to the defect under nhtsa campaign id number 05v270000 (electrical system: wiring). The vin was not included in the recall. The...

Read the full complaint

vehicle was currently being repaired. The manufacturer was made aware that the failure occurred intermittently. The failure mileage was 97,000. The vin was unavailable. Updated 09/07/2011 *ln *tr

Filed Incident Electrical systemNHTSA 10405757
Electrical system

Tl*the contact owns a 2000 ford excursion. The contact stated the engine was turned off, and failed to restart. A certified technician replaced the fuse relay. Seven months later, the identical failure recurred and the fuse relay was replaced a second time. Most recent, the fuse relay was replaced each time the engine was turned off in order for the vehicle to restart normally. The vehicle was taken to an independent mechanic who was unable to duplicate the failure. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.

Filed Incident Electrical systemNHTSA 10404044
Fuel systemElectrical systemAcceleration & cruise control

Tl* the contact owns a 2004 ford excursion. The contact was stopped at a light when the vehicle attempted to accelerate forward. The contact stated that the brakes were applied during the failure. The following day, the vehicle failed to start and was towed to an authorized dealer. The dealer advised him that the vehicle would need a new injection control pressure sensor and a fuel injection control module. The vehicle was not repaired. The contact referenced nhtsa campaign id number: 05v27000 (electrical...

Read the full complaint

system: wiring) and was advised by the dealer and the manufacture that his vin was not included in the recall. The approximate failure mileage was 82,300 and the approximate current mileage was 82,400. Updated 02/03/11*lj updated 02/11/11

Filed Incident Fuel system, diesel · Electrical system · Vehicle speed controlNHTSA 10369427
Electrical system

Tl* the contact owns a 2004 ford excursion. When making left turns the vehicle will stall. The vehicle was taken to the dealer, and the computer and sensor were replaced at an expense of $1100. The vehicle was previously repaired according to recall # 05v270000 (electrical system:wiring). The failure mileage was 138,883.

Filed Incident Electrical systemNHTSA 10293222
Electrical system

Tl* the contact owns a 2004 ford excursion. The fuel injection control module failed, which caused the engine to stall without warning. The manufacturer was notified, and he was advised that he vehicle identification number was excluded from recall #05v270000 (electrical system:wiring). He was not eligible for a free remedy. The failure mileage was 96,000. Updated 12/09/09 *bf updated 12/11/09.*Jb

Filed Incident Electrical systemNHTSA 10290987
Electrical systemVisibility & wipersBody, doors & structure

Tl*the contact owns a 2004 ford excursion. The contact stated that the entire vehicle is electronic. He stated that the speedometer does not work, the windows occasionally roll up and down, the door locks do not open, and the temperature gauge works intermittently. The vehicle was purchased used and the dealer stated that they cannot repair the failures. The vin is not included in the recall. The nhtsa campaign id number was unknown. The failure mileage was 90,000.

Filed Incident Electrical system · Visibility · Latches / locks / linkagesNHTSA 10244874
SuspensionEngine & coolingFuel systemTransmission & drivetrainElectrical systemSeats & seat belts

We purchased 2004 ford excursion with the 6.0L diesel engine new in february 2004. It has been to the dealer now 2 times for the back up sensor, approximately 5 times for the turbo, unable to count the number of times for the lack of power, the vent windows not working, 3 times for the motor on the power drivers seat, ball joints 1 time, and now other front end parts. This vehicle is primarily used to go to church and travel with the entire family on the weekends for day trips. We have had it to graham ford several...

Read the full complaint

times, germain ford several times, (both are in columbus, ohio) and the last place we have it is donley ford in mount vernon, ohio. We can get a full history of all repairs on this vehicle if needed. There have been so many things gone wrong with the truck that it is difficult to keep track. The service advisor is now telling my wife to "just trade it in". We just want all of the problems fixed correctly and find the cause of the electrical failures/issues/problems instead of just fixing what breaks and not fixing the cause. We paid 50,000 bucks for this vehicle and have had nothing but problems. The start was when we wanted to go to maine and could not take it but had to take our older conversion van. *Tr

Filed Incident Suspension · Engine and engine cooling · Fuel system, diesel · Power train · Electrical system · SeatsNHTSA 10244578
Electrical system

2004 Ford excursion has a problem with stalling. *Nj the consumer stated the recall was not being honored. Recall # 05v270000. The consumer also stated the alternator was replaced less than a year ago. *Jb

Filed Incident Electrical systemNHTSA 10243708
Electrical system

Vehicle would stall while driving and surge while stopped. This happened due to the wiring harness being burned and the fuel injection control modulator wiring harness as well as the icp sensor has to be replaced. This is a recall issue for my year and make but not my vin. The mechanics said it will happen again, it is not safe to drive with this risk. *Tr

Filed Incident Electrical systemNHTSA 10242479
Electrical systemFire

Tl*the contact owns a 2004 ford excursion. After the vehicle had been parked for eight hours, the contact smelled something burning when it was restarted. He noticed smoke coming from the engine compartment and the vehicle burst into flames two minutes later. The fire burned through the air conditioner hose and erupted. The eruption also extinguished the fire. The contact is a mechanic and he inspected the vehicle. He was able to start the vehicle and drove to the dealer. The dealer stated that the failure...

Read the full complaint

was caused by a loose wire. The manufacturer stated that the vin was not included in nhtsa campaign id number 04v327000 (electrical system:battery) for the 2003 models. The current and failure mileages were 56,880. Updated 03-04-08 *bf the consumer believed the problem he experienced was related to the recall. Updated

Filed Incident Electrical systemNHTSA 10215708
Engine & coolingElectrical system

Tl*the contact owns a 2004 ford excursion. While driving between 35-40 mph, the vehicle stalled and then shut off. The vehicle was towed to a mechanic and they replaced the number 1 and number 3 fuel injectors. The dealer stated that the vin was not included in nhtsa campaign id number 05v270000 (electrical system:wiring). The current mileage was 130,994 and failure mileage was 108,480. Updated 09/10/08 *bf the alternator, control module for the heating and ac system, and cooling system were replaced. Updated 09/19/08. *Jb

Filed Incident Engine and engine cooling · Electrical systemNHTSA 10213277
Electrical system

Tl*the contact owns a 2004 ford excursion. After starting the vehicle and placing it in drive or reverse, it accelerates or surges on its own. The vehicle now surges or revs as if it is trying to surge when driving or idling. The failure occurs at speeds between 0-25 mph. The vehicle has not been taken to the dealer. The contact was informed that his vin was excluded from nhtsa campaign id number 05v27000 (electrical system:wiring). The purchase date was unknown. The current mileage was 101,000 and failure mileage was 95,000.

Filed Incident Electrical systemNHTSA 10206752
Electrical system

Tl*the contact owns a 2004 ford excursion. While driving between 25 and 65 mph, the vehicle stalled. The vehicle also failed to accelerate when the pedal was depressed. After being parked for 3-4 hours, the vehicle would operate normally for thirty minutes before the stalling began. The check engine light illuminated after the failure, but dimmed when the vehicle was restarted. The contact took the vehicle to the dealer twice and to a mechanic another two times. On one occasion, he was informed that the fuel filter was clogged. Nhtsa campaign id number 05v270000 (electrical system:wiring) was referenced. The current mileage was 75,100 and failure mileage was 68,000.

Filed Incident Electrical systemNHTSA 10203959
Transmission & drivetrainElectrical systemBody, doors & structure

I own a 2004 ford excursion which has on two occasions failed to start and was towed to fairview ford. The first occurrence the dealer replaced the camshaft sensor and reflashed the computer. The second incident the car was also towed by roadside assistance from my driveway. The tow truck driver was also unable to start the vehicle. I was contacted later in the day by my service advisor saying that the vehicle started fine and they were unable to duplicate the problem. On a third occurrence the vehicle...

Read the full complaint

stalled in a parking lot and would not restart for my wife. After shopping for approximately 45 minutes my wife returned and was able start the vehicle and it was driven strait to the dealer. The dealer was again unable to duplicate the problem. I have also given fairview ford six attempts to fix misaligned doors that are visibly misaligned and cause the door to have to be slammed to close them. The doors were misaligned when purchased and the dealer is unable to fix them. At one point after the dealer tried to align the front drivers side door I could stick my fingers in between the door and the body all the way to the outside with the door closed. The vehicle has been in the shop a total of 35 days and now has 16k miles. My wife is afraid to drive the vehicle with my three young children for fear of stalling and causing an accident. *Nm

Filed Incident Power train · Electrical system · StructureNHTSA 10138060
Fuel systemElectrical system

Dt: the caller had recall work done on his vehicle and it is running worse than before. Received recall 05s34 concerning injection control pressure sensor and wiring harness. Now, the vehicle has problems that it did not have before the recall. Vehicle stalls when engine is cold/hesitates and surges while accelerating. Took vehicle to the dealer 4 times since july 19, 2005, and is now was taking it to them again. Manufacturer can not be reached. *Ak the dealer's service manager told the consumer that he may have to live with the engineering change ford made to the engine when recall 05s34 was completed on july 19, 2005. *Nm

Filed Incident Fuel system, gasoline · Electrical systemNHTSA 10132840
Electrical systemFire

While driving 35 mph, a fire started under the hood. Consumer managed to pull over , and put out the fire. Had the vehicle towed. Dealership was notified, but did not resolve the problem. *Ak

Filed Incident Electrical systemNHTSA 10116969

Ford Excursion electrical complaints by year

Excursion electrical problems, every year

Had a electrical problem with your 2004 Excursion? Tell other owners.

Your experience goes live straight away and helps every owner and buyer who checks this vehicle. Anonymous, free, no account.

Overall, how would you rate it? *

0/4000 · Please leave out names, phone numbers and your full VIN.

By posting you confirm it's your own, honest experience and agree to the rules. Safety defect? Also report it to NHTSA - that's how recalls start.

Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data

Owners helping owners

Know before you drive.

Every experience you share - good or bad - shows on that vehicle's page and helps the next owner and buyer. Two minutes, anonymous.

Share your experience