2002 Ford Excursion Electrical problems

Was driving on highway and vehicle all of a sudden lost power kept pressing the gas pedal and it wouldn't go as felt like you wanted to turn off it would stall we have checked everything in the truck engine everything and everything seems good transmission does not have any metal shavings I did notice that for some reason the electrical panel have melted it was all completely melted and they believe that the transmission is also melted and stuck together I'm not sure because we still haven't I mean transmission has...

I have several issues, both back door windows have fallen off track and won't stay up. This happened in september of 07 and a few months later the second rear window did the same. I have to use clear packaging tape to hold them up. The key to the ignition will not turn unless I use something with a hard end and tap it several times. When the ignition problem first happened in september of 2006 I called ford road side service and they recommended tapping the key several times and said they had a growing complaint of...

Tl*the contact owns a 2002 ford excursion. In an attempt to drive the vehicle, the contact smelled burning wire. The vehicle was taken to a dealer and they discovered a melted fuse box. The fuse box was replaced, but the dealer could not explain the cause of the failure. The current mileage was 92,232 and failure mileage was 92,230.

Tl*the contact owns a 2002 ford excursion. While driving 70 mph, the vehicle's horn began to sound intermittently. The contact had to pull the horn pad out of position. The dealer has the vehicle but was unable to determine the cause of failure. The current mileage is 200,000 and failure mileage was 150,000. Updated 06/14/07.*Jb

Kept having to replace fuse #45 on my 2002 ford excursion limited diesel 4x4. After putting into any gear, go to give it fuel it would nt do anything. Researched the internet and found that there was others with ford truck 1999-2003 having same problem and read what they did to fix it. Apparently in the gear shift, there are 3 very short wires that were fraying due to be pinched. So since it was not under warranty we had to have the steering box cover removed and there it was, the wires were almost completely...

The cps (crankshaft position sensor) failed with no warning at all. This is one of those things that is not a moving part, and should have lasted hundreds of thousands of miles. I understand there have been a lot of complaints about it. Sign me on to that bandwagon. *Nm

In june of 2003, a 2002 ford excursion limo suffered a fire loss under the hood. The vehicle was parked without the engine running or power switches on. It had not been used for several hours. While an employee was in the passenger area cleaning the limo, he noticed the vehicle was on fire underneath the hood. The fire originated on the left side of the engine compartment. Damage to wiring and other combustibles was extensive. No cause of the fire was determined. After hearing of the cruise control...

The electronic controller for the over drive lock switch is shorting out in my 2002 ford excursion. I experienced a problem with the gauges turning off while I was driving around atlanta, ga with my family. The battery went dead because the fuse that controls the dash gauges blew. The alternator quit charging the battery, and the gauges quit working. I did not notice this problem until I was stopped at a red light and the engine died. I restarted the car, put it in drive and when the light turned green the...

There was a strong smell coming out of the air conditioner vents in the warm months. That I describe as a urine odor. The dealership installed a fan in the air conditioner that comes on 15 minutes after the car is turned off to dry out the air unit.

Ford excursion 2002, blew out spark plug through piston cap,.. After $5000.00 In fixes, I went to pick it up, and it blew up again on the way home from the dealership. I lost power on the freeway going 65 miles per hour, and almost crashed. Ford was not at all helpful, and even though I am a very good customer, could care less about me, the danger of the v10 engine blow ups, or about their customers lives.... Is their any way you guys could make them do the right thing ??? Isn't there any law or organization that can help us ??? *La (per 10/24/2005 phone call with consumer: no crash, no injuries, no fire, no property damage other than engine damage - c. Rose)

The vehicle experienced electrical and suspension problems. The suspension problem caused the tires to wear prematurely. Please provide any additional information. *Nm

The vehicle has a front suspension problem which causes the vehicle to vibrate, the vehicle has been to the dealer 3 times but the problem still exist, both driver side doors are misaligned with respect to the fender trim, the differential was originally misaligned with respect to the rear fender trims, now the differential is properly aligned and the consumer questioned the technicians who stated that they did nothing to correct the misalignment, the consumer feels this is a definite safety problem if the...