2003 Ford Explorer Problems, complaints & recalls

The contact rented a 2003 Ford Explorer. The contact stated that while driving at an undisclosed speed with the seat warmer activated, after arriving at a Rest Stop and exiting the vehicle, the contact became aware that a blister had formed on the back of her left thigh. The contact attributed the blister to a burn sustained while using the driver's side seat warmer. No warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic, but instead was returned to the rental company. The manufacturer was not notified of the failure. The failure mileage was 43,253. The VIN was not available.

There is a crack down the middle section of the liftgate for quite some time. The liftgate has been unlocking and opening automatically by itself. On only rare occasions has the liftgate opened all the way while driving. On the morning of 7/28/2022 while the vehicle was parked in my driveway the liftgate was discovered to have again unlocked by itself and opened slightly and now with one of the two hinges holding the glass sheared leaving the liftgate glass hanging by only one hinge. With the glass now hanging...

Head lights are cloudy given poor visibility. Back hatch door has a crack.

The contact owns a 2003 Ford Explorer. The contact stated that while driving at approximately 25-35 MPH around a curb, the driver thought that the tire was flat. The contact pulled off the road and noticed that three of the wheel studs on the driver's side rear wheel had sheared off. The vehicle was towed to an independent mechanic and it was confirmed that the studs had sheared off and that there was also a fractured wheel stud on the passenger's side rear wheel. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 115,000.

Hello my name is [[redacted]] just writing you cause my neighbors have program my vehicle meaning they hack my 2003 explore pretty much they want to take over my driving they trying to dominate me in this matter when in reality is not going to be possible that's why I come to your people's corporate plus they have invade my family privacy they have a gang organization watching me every where I go had few confrontation they just want me to confront them so they could put me in jail this is not going to happen i...

drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.

The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety of others safety was put at risk. I did contact Ford Manufacturer on her behind of the airbags and they said there is nothing they can do for her with the vehicle being totaled out. But my main problem is why these...

Was closing back hatch and glass window literally exploded! Vehicle was parked in my yard.

The transmission is shot I cant put it in gear and me and my husband were almost killed but were able to put it in 2nd gear to roll it to the shop. The 4wheel drive got stuck in 4 wheel low and would not shift at all. When we turned the car on it would rev up to 5 but only go 2 miles an hour.

Tl* the contact owns a 2003 ford explorer. The contact stated that the front driver's side wheel detached due to the control arm being corroded. The contact called elder ford (777 john r rd, troy, mi 48083, (248) 825-8646) and was advised to schedule an appointment. The vehicle was later taken to an independent mechanic who diagnosed that the metal of the upper control arm was not a good metal; therefore, the control arm was corroded through and needed to be replaced. The vehicle was not repaired and was not taken to a dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

Takata recall .. The smell of fuel inside the cab and outside is really bad. It's making me sick and giving me headaches. The truck doesn't run right and the mileage is awful.

Shifter broken inside steering column. Stopped at a gas station when putting into park it broke. Had to keep my foot on brake paddle for 2 hours until two truck arrived

"Takata recall" airbag light keeps blinking with the seat belt noise. Changed the light bulb from the dash board and now the airbag light stays on but will not connect with mileage.

2003 Ford explorer. Consumer writes in regard to defective throttle in model vehicle. *As *tr

Vehicle was in motion, moving through an intersection on a city street and involved in an accident. No air bags deployed at all.

Engine stops while driving (stalls in motion while turning on street and highway) restarts without problem, has happened twice now 30 days apart.

Body mounts deteriorated crumpled.Body down on frame causing irregular ride control

2003 Ford explorer. Consumer writes in regard to malfunction to company's rear wheel bearing. *As *tr

Tl* the contact owns a 2003 ford explorer. Within a month of owning the vehicle, an independent mechanic stated that the brake system needed servicing, including the rotors and brake pads. The vehicle was not diagnosed by a dealer. The manufacturer was notified and had not issued any brake system recalls; however, there were ten tsbs for the brake system. The vehicle was not repaired. The failure mileage was not available.

This suv's are getting hot during the texas weather, why are not including a solar fan installed to keep the air circulating in the suv, technology is changing why are not adding the system ???

Rear window lower panel plastic cracking up, replaced three times, still cracking due to no support and bending too much, I called ford does not care if continues cracking up, it looks ugly also panels can cause an accident to other cars getting into their windshields loose parts. They know about the problem and not fixing it.

The problem the seat belts does not have enough tension to retract consequently getting on the door lock mechanism, causing the door not to lock, to stay open unsecured also damaging the seat belt, it does no have a way to increase the tension which it should have. It damaged my door seal, my lock mechanism and the belt too.

Tl* the contact owns a 2003 ford explorer. When attempting to close the rear window, the contact noticed that the rear liftgate window hinges were cracking and were tilted on one side. The contact, a certified master technician, stated that the window needed to be replaced. The contact called fort mill ford at (866) 680-5276 (located at 801 gold hill rd, fort mill, sc 29708) and was informed that the vin was not included in any recalls. The manufacturer was notified of the failure and referred the contact to nhtsa. The approximate failure mileage was 133,000.

Exhast manafold has crack in it and screws came lose and fell out wihich created fumes in car.

All side airbags deployed without accident. Deployment happend while my wife and 4 year old son was in the vehicle driving approximately 30-40 miles per hour down a straight road in long valley new jersey. This road is smooth, level and free of pot holes etc. Unable to see because of the downed airbags and smokey dust like material from the airbags she pulled off the road as best she could.