2017 Ford Explorer Problems, complaints & recalls

Exhaust and Carbon Monoxide in the cab of the vehicle when going up hill or accelerating

Received recall notice 6/2025 regarding the A pillar covers and scheduled for repair. Ford representative came out and placed black adhesive tape on the A pillars and windows but did not replace the covers. It is now 11/2026 and no word on when pillar covers will be replaced.

The contact owns a 2017 Ford Explorer. The contact stated that while entering the vehicle, the contact became aware that the driver's side B-pillar door trim was detaching. The contact associated the failure with NHTSA Campaign Number: 25V347000 (Structure); however, the VIN was not included in the recall. The dealer was contacted and stated that the cost of the repair was not covered because the VIN was not included in the recall. The failure mileage was approximately 90,000.

About 3 years and 3 months after a Power Control Module reflash was done in March 2021 under the Customer Satisfaction Program (CSP) 20B27, vehicle was brought to Ford dealership on 06/07/2024 with mileage at 79,730 for multi point inspection due to vehicle runs rough and hard time accelerating. Diagnostic code was P0316. Service tech recommendation was to replace engine for $14,000.00 including parts and labor (declined recommendation). Brought vehicle to another dealership but found no codes. Instead replaced...

Vehicle losses power randomly during acceleration, may not stay in park without parking brake on. Shudders badly and shifts harshly decelerates without warning. Nearly has caused collision when merging onto roadways due to lack of control of acceleration, have had to slow onto shoulder multiple times.

The contact owns a 2017 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 25V347000 (Structure) however, the parts to complete the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue.

B-Pillar trim on drivers side detached/broke in half and flew off in traffic. Since then, electrical panel on the driver door messed with the locks. locks no longer work, back tailgate ajar warning is on (even though the tailgate is closed) unable to open to open the tailgate (stuck in lock)

The contact owns a 2017 Ford Explorer. The contact stated that while the vehicle was parked, the passenger-side rear tire was low on air pressure. Upon inspecting the vehicle, the contact observed wires exposed on the inner tread of the tire. Additionally, the contact inspected the driver-side rear tire and observed exposed wires sticking out from the inner sidewall. The contact stated that NHTSA Campaign Number: 21V537000 (Suspension) was completed in October 2025. The contact associated the tire failure with the recall. The dealer was notified of the failure by phone. The manufacturer was notified of the failure. The failure mileage was approximately 165,400.

This is a second complaint for the same vehicle. Complaint number 11770400, filed today, understated the failure history, and I am filing this one so the complete record is in the database. Vehicle: 2017 Ford Explorer Platinum, 3.5L EcoBoost V6, VIN [[redacted]]. The first turbocharger failure occurred in 2023, at under 110,000 miles, and was repaired at a cost of approximately $2,900. A turbocharger was replaced again in August 2025 at a cost of $2,895. The catalytic converter was replaced in March 2026 at a...

Both turbochargers on my 2017 Ford Explorer Platinum with the 3.5L EcoBoost V6 have failed. The first turbocharger failed and was replaced in 2025. On August 10, 2026, at about 138,000 miles, the second turbocharger failed: the vehicle lost power and poured thick white smoke from the exhaust as engine oil burned off, making it undrivable. Sudden power loss and heavy smoke while driving are serious safety hazards. This failure is consistent with the turbocharger oil supply tube defect in NHTSA recall 16V925000 for...

Sudden catastrophic engine failure due to coolant mixing. This resulted in a safety issue due to time and location of the event. From online consumer reports this event happens just after 100,000 miles to the 2017 Ford Explorer SUV's and is a KNOWN event that Ford has NOT disclosed. Regular maintenance can NOT prevent this event and stopping the use of the vehicle only helps if it is immediate and the problem known. That Ford hasn't disclosed this possibility of failure nor suggested preventative measures is a safety concern.

Engine hesitated, kept hesitating/slowing down until 2017 Ford Explorer just stopped. Towed SUV to Koons Ford Service Center. Charged $200 for diagnostic assessment. Informed that oil/coolant mix due to water pump failure. Diagnose: replace Engine Long Block and Hardware and thermostat. Costing $11,195.04 for job. Never mentioned what happened to cause this. At another dealership, mechanic told us of the NHTSA Recall 25V685000 regarding this malfunction. Note: Koons Ford has had a "history" with this SUV, only working on recalls when we push the issue. Also, requiring a $200 diagnostic charge each time the vehicle is seen. This location is where we bought the vehicle.

1. Rubber is falling off the windshield and hood. This is a ford issue and they refuse to repair this. It appears to be heat related and the car was sold in an area with high summer temperatures. It is cracked and peeling at the bottom of the windshield causing rain and leaves to seep into the engine area. This could start a fire hazard if it's not repaired. Quoted me 12k to fix (more than the cost of getting another car that is less dangerous). 2. Inside auto same issue is happening with the ford installed...

The back up camera is cloudy with very limited visibility at night. My safety is at risk backing the car up. Yes available for inspection. I have told the dealer. I am unsure if they actually looked at it at night. This issue has been happening for a few years and now it is much worse. I learned of this sight to report it to. There are no lights or warning lamps.

B-pillar is coming off, not allowing keypad to lock/unlock. Remedy has not come available in over a year.

Ford Safety Recall 24S02 was previously recorded as completed on my 2017 Explorer after this dealership inspected the A-pillar moldings. The recalled A-pillar molding subsequently became severely loose and detached while I was driving on the highway. I am concerned that the recall inspection/remedy may not have been properly performed before the recall was reported completed. The dealership initially attempted to charge me for replacement and is now submitting the matter to Ford for review. I am requesting review of the dealership's original recall documentation and the circumstances under which the recall was closed.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to perform the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the driver's side and passenger's side B-pillar trims detached from the vehicle. The contact used tape and hot glue to reattach the B-pillar trims to the vehicle. The dealer was notified of the failure and confirmed that the part was not yet available. The failure mileage was approximately 160,000.

See attached document for complaint.

The contact owns a 2017 Ford Explorer. The contact stated that while driving 70 MPH on the interstate, the engine light illuminated and the vehicle stopped in the middle lane. The contact was able to maneuver and coasted the vehicle over to the side of the road. The instrument panel was illuminated afterwards. The contact stated that the failure was like NHTSA Action Number: DP26008 (Engine and Engine Cooling). The vehicle was towed by Firestone and then towed to the local dealer, where the engine was replaced. The...

The contact owns a 2017 Ford Explorer. The contact stated that while driving, the driver's side B-Pillar trim detached and was hanging off the vehicle with the wiring exposed. The contact used a bungee cord to secure the driver's side B-Pillar trim to the vehicle. The dealer was contacted by phone and made aware of the failure. The vehicle was taken to the dealer, and the contact was informed that the parts to repair the vehicle were unavailable. The contact was informed that the parts were unavailable until July...

Ford diagnosed the A-Pillar recall (Ford Recall Notice 24S02) condition on January 13, 2026, confirmed that the vehicle requires the recall repair, and placed the vehicle in the repair queue. The obstacle preventing completion of the repair is not the dealership. Rather, it is Ford Motor Company's continued inability to provide sufficient replacement parts to its dealer network. I have been advised that the waiting list for this repair is approaching 300 customers and the dealer is receiving only a very limited...

There is a driver's safety-restraint malfunction with a failure mode such that the tongue (male end of seat-belt) will not insert normally into the buckle (female end) unless the red release button is depressed. The driver buckle failure results in a failure in the vehicle's personal safety system. The component has not been inspected or confirmed by a dealer, as Ford Motor Company has indicated this will be an out-of-pocket cost replacement due to the extended warranty on this buckle no longer being applicable - Ford issued voluntary special field action 23L06 related to the driver's side buckle that expired March 31 2025.

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V316000 (Structure); however, the failure recurred with the front and rear driver's side roof rail covers detaching. The contact also received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact...

Ever since my B pillar came off my car my cabin lights stay on longer than usual and my trunk cant be opened, both being an inconvenience. Dealer agreed the lights stay on because of what broke off but since theres no remedy they cant do anything about it. Ive already had to purchase a battery and will soon prob going to need to again but ford will not pay for one despite it being they're fault.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V347000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the front driver's door B-pillar trim had detached, causing the liftgate to not open as needed. The message "Liftgate Ajar" was displayed with an audible chime, and the trunk warning light was illuminated. The manufacturer was notified of the failure by phone and confirmed that parts were not yet available for the recall repair. The failure mileage was approximately 120,000.