- The problem
- On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. This could result in inadvertent operation of the fifth wheel slide control.
- The risk
- If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.
- The fix
- Dealers will relocate the msva 7-pack to a less water intensive environment. A new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. The recall began on august 5, 2005. Owners may contact international at 1-800-448-7825.
Vehicle safety record
2002 International 7400 Problems, complaints & recalls
No owner complaints about the 2002 International 7400 have been filed with NHTSA. It is covered by 5 recalls, the latest in April 2005 for the fifth wheel assembly.
NHTSA data checked
DMore problems than a typical 7400 year, for its age
- Complaints
- 0
- Recalls
- 5
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2002 International 7400 recalls 5
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar i-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
- The risk
- THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.
- The fix
- Dealers will inspect for any chafing. If there is no evidence of chafing, a saddle clamp will be installed. If there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. The recall began on august 16, 2004. Owners should contact international at 1-800-448-7825.
- The problem
- On certain trucks equipped with dt466 or dt530 1308 style engines and 4x4 or 6x6 capability, the universal joint between the front drive shaft and drive axle could come in contact with the engine oil filter under certain braking conditions.
- The risk
- This could cause a loss of complete engine oil which could result in the engine shutting down and increase the risk of property damage, personal injury, or a crash.
- The fix
- Dealers will install a shorter oil filter and adapter. Owner notification is expected to begin april 29, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- The problem
- Certain heavy duty trucks fail to comply with the requirements of federal motor vehicle safety standard no. 104, "Windshield wiping and washing systems." Due to the design of the windshield washer pump motor circuit, the system's ability to function is impaired when it is full of frozen water and the pump motor shaft is locked or frozen (cannot rotate).
- The risk
- Any resultant reduced visibility could cause a crash.
- The fix
- Dealers will install a new 10 amp fuse in place of the 5 amp fuse and a new 10 amp label will be placed over the original 5 amp designation on the fuse panel label. Owner notification began on june 27, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
- The problem
- On certain heavy duty trucks, the fuel line is routed too close to a turbo charger outlet/exhaust pipe. If an interference condition occurs between the fuel harness and the exhaust pipe, the fuel line inside the reflective heat wrap could melt due to excessive heat.
- The risk
- The melting of the line could result in immediate engine shut down, increasing the risk of a crash.
- The fix
- Dealers will inspect the vehicles for proper routing of the fuel harness. If the harness is routed near the exhaust system, a new fuel harness will be installed. Owner notification began december 27, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
What owners say
Be the first 7400 owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2002 International 7400 yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
International 7400: every year compared
All 7400 years2002 International 7400 vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2002 International 7400 | 0 | 5 | D | |
| 2002 International 4300 | 5 | 9 | D | Compare |
| 2002 International 3800 | 4 | 2 | C | Compare |
| 2002 International 4000 | 1 | 3 | D | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2002 International 7400
Does the 2002 International 7400 have any recalls?
Yes - NHTSA lists 5 recalls for the 2002 International 7400: fifth wheel assembly (April 2005); cables (June 2004); universal joint (March 2004); windshield wiper / washer (April 2003) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2002 International 7400 had?
None have been filed with NHTSA so far.
Is the 2002 International 7400 a reliable vehicle?
Its Safety Index is 34 out of 100 (grade D: more problems than a typical International 7400 year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
Which International 7400 years have the most complaints?
2006 (2), 2005 (1), 2012 (1). See every International 7400 year compared.
What should I do if my 2002 International 7400 has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data