Steering
390 complaints filed with NHTSA about the Tesla Model 3's steering. Loss of power steering, stiff or loose steering, wandering, column and rack problems.
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles operating software prior to 2023.38.4. The printed circuit board for the electronic power steering assist may experience an overstress condition, causing a loss of power steering...
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe...
SUPPLEMENTAL SAFETY FILING FOR EXISTING NHTSA TRACKING #11776730 Updating my initial November 9, 2026 report with Tesla's November 9 service invoice, post-repair red steering wheel failure, and daily Service Mode overheating DTC logs starting on delivery day (November 1)."
1. Full Self Driving computer complete system failure. Happens everyday. 8 days still has same problem. 2. Problem showed itself 30 minutes after taking possession of the car. Gave me a panic attack because the car was driving itself and then "TAKE CONTROL IMMEDIATELY!!" was on the monitor. This caused me to jerk the wheel while in heavy traffic on [[redacted]] and I hit the brakes and almost caused an accident because I thought the car was going to crash. 3. Problem has happened everyday/3-5 times a day since...
taking ownership [[redacted]]. I checked the fault logs on [[redacted]] and there are over 100 incidents of the Full Self Driving computer overheating with system errors. 4.Car is currently as of [[redacted]] at the Norfolk VA Tesla dealership. And I am in a loaner. 5.There were no pre warning lamps or messages when I got the car. The problem appeared 30 minutes into my ride back to Hampton VA. It started with loud alerts and saying "TAKE CONTROL IMMEDIATELY". The photos attached are just a sample of how many times this problem has occured. The last photo is a log of faults. I was able to reach this data [[redacted]] and the faults happen frequent like this every day I have had the car. There are about 100 faults as of [[redacted]]. Tesla Norfolk Service Department has the car as of [[redacted]]. I feel they sold me a car with a DEFECTIVE CRITICAL SAFETY DEVICE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2018 Tesla Model 3, VIN [[redacted]]. Rear-right ABS wheel speed sensor failed 3-4 days after Tesla Burbank replaced it on [redacted] (invoice [redacted]). First alerts [redacted] (ABS disabled, Drive with caution, TPMS). Failure confirmed [redacted] (AEB unavailable). Returned from vacation [redacted]; Tesla replaced same part again (invoice [redacted] $167.76). Tesla notes state only that sensor "was cut"; no animal damage recorded.I photographed the failed sensor [redacted]. It shows a single clean angled cut...
through the black jacket with conductor and red insulation on the same flat face. No tooth marks, scalloped bites, shredded insulation, or nesting material - a shear, not rodent damage.Service Manager [[redacted]] first blamed a rabbit, then wrote it "was an example" and that Tesla does not need droppings, nesting, or chew marks to call a severed harness outside damage. He has no photos from the 8/18 install; the tech is on leave. Two emails to [[redacted]] went unanswered. Related BAR complaint filed (ref [redacted]).Rear wheel speed sensor feeds ABS, traction control, and Automatic Emergency Braking. Failure disables these safety systems. A part that fails days after Tesla service with an undocumented "cut," followed by a warranty denial based on inference rather than evidence, indicates possible workmanship or installation issues that could affect other vehicles. Requesting NHTSA review of Tesla's service practices for this component.Tesla Service Burbank, [[redacted]], [[redacted]]. [[redacted]], [[redacted]].[[redacted]], [[redacted]], [[redacted]] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The steering wheel cover material (PUR/vegan leather) has separated, cracked, and peeled extensively, primarily at the 3 o'clock and 9 o'clock hand positions. This matches Tesla Service Bulletin SB-23-32-003 regarding steering wheel material separation. The material is delaminating from the underlying structure under normal use. No hand lotion, sanitizer, or other chemicals have ever been applied. Photos available. Vehicle is still under the Basic Vehicle Limited Warranty (4 years/50,000 miles).
Heard a clunk noise when the vehicle turned at a low speed. Inspected the vehicle but nothing seemed amiss. No digital warnings either. Started driving but the steering was weird and pulled to the left. Then the front left tire started shredding and the wheel was displaced. The tow truck guy said that the suspension seems to be the culprit. The car is now on just the wheel. Tesla collision has still not looked at it but gave a quote of 5-6K to start and going up to 12K or more (if the HV battery got damaged). FYI, tire pressures were normal when this happened.
I am reporting a premature and severe multi-component front suspension failure on my 2020 Tesla Model 3 that poses a serious steering and control safety hazard. While driving and turning at low speeds (such as parking), the front end began emitting a loud mechanical clicking and popping sound. A certified technician diagnosed the vehicle and found that multiple critical suspension components had failed or worn prematurely at just 55,089 miles. The failures include the front lower lateral links, front lower...
compliance links, front upper control arms, stabilizer bar and front end hubs failing completely and simultaneously. This is a well-documented issue among 2018-2020 Model 3 vehicles and is currently the subject of an active NHTSA Preliminary Evaluation investigation regarding front lower lateral link detachment. Premature failure of these load-bearing suspension components compromises the vehicle's structural integrity, accelerates extreme tire wear, and presents an immediate risk of component separation or sudden loss of steering control at high speeds. Tesla should issue a safety recall for these defective suspension components and compensate owners for out-of-pocket repairs.
The steering wheel makes a grinding noise when it automatically adjusts (when the car starts). It also makes the same grinding noise when I adjust it
I drove over a bump in the road and all of a sudden the car started making a very loud clunky noise in the front suspension. I was close to home so I turned around and drove it back home for inspection. I found the lower control arm on the suspension is completely disconnected because the bolt is backed out of the joint. The steering had occasionally made some creak sounds in the past but it never felt loose. Seeing the lower control arm disconnected could have severely limited the steering of the vehicle thus this seems like a serious safety issue. I have scheduled an appointment for repair with Tesla Service.
Subject: Vehicle Safety Complaint - 2024 Tesla Model 3 RWD - Sudden Loss of Steering Control and Total-Loss Crash I am submitting this complaint concerning a serious safety incident involving my 2024 Tesla Model 3 Rear-Wheel Drive. While driving manually on a wet highway in [[redacted]], my vehicle suddenly moved sideways and began to lose control. I was not using Autopilot or Full Self-Driving. Despite my attempt to maintain control using the steering wheel, I was unable to steer the vehicle back under control....
The vehicle left the roadway and entered a pond, resulting in a total loss. I have video footage documenting the incident and surrounding road conditions. I am concerned that this incident may have involved a vehicle safety defect, potentially involving the steering system, electronic stability control, traction-control system, or another vehicle system responsible for maintaining directional control. I understand that wet-road conditions and hydroplaning are possible explanations; however, I believe the reported inability to regain steering control warrants a thorough technical investigation rather than assuming that weather alone caused the crash. I request that NHTSA review this incident for potential safety implications involving the 2024 Tesla Model 3 RWD and determine whether similar complaints or technical findings may indicate a broader safety issue. I also request that Tesla preserve all available vehicle telemetry, diagnostic logs, fault codes, steering-system data, wheel-speed information, and electronic stability-control records associated with the incident. Vehicle information * Make and model: Tesla Model 3 * Model year: 2024 * Drivetrain: Rear-Wheel Drive * Driving mode: Manual * Incident location: [[redacted]] * Weather: Wet roadway / rain * Outcome: Vehicle left the roadway and entered a pond; total loss * Evidence available: Video footage INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The front left and right lower link assemblies suffered premature structural failure and required immediate replacement at 74,068 miles due to a loss of steering stability. The repair was completed at a Tesla Service Center out-of-pocket for a total cost of $1,564.04
In a rented 2022 TESLA MODEL 3 entering a right veering on-ramp, the vehicle failed to respond to driver steering inputs at normal speed. I released the accelerator and there was no degenerative braking. I applied brakes, but the ABS was violently shaking without stopping and I noticed something illuminate on the computer screen. Unable to turn the steering wheel at all, we made severe impact with the left guardrail injuring both my wife([[redacted]]) and I. The Steering Assist Reduced warning light remained illuminated after the accident and I took a picture. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2021 Tesla Model 3 with approximately 110,000 miles. Loud creaking/squeaking noise from the front suspension (primarily passenger side) when driving at low speeds over bumps and during slow turns. The noise matches the known front upper control arm ball joint water intrusion issue documented in Tesla service bulletin SB-20-31-006 and widely reported by other Model 3 owners. No warning lights, messages, or other symptoms. The component is available for inspection. I have scheduled a service appointment with Tesla...
but the vehicle has not yet been inspected or repaired by the manufacturer or any independent shop. While currently only a noise (NVH) issue, progressive wear of this ball joint can lead to play in the suspension, uneven tire wear, degraded steering feel, and potential loss of control if the joint fails.
The contact owns a 2019 Tesla Model 3. The contact stated that while operating the vehicle, the service controller warning light illuminated and the vehicle was taken to the local dealer service center and was diagnosed with steering rack, wiring harness, and control module failure caused by corrosion from water. The steering rack, control module, and wiring harness were replaced and the vehicle was repaired. The manufacturer was not contacted. The failure mileage was 13,721.
On October 16, 2026, my 2024 Tesla Model 3 initiated a standard, factory-prompted over-the-air (OTA) firmware update. During this automated install process, the car's firmware crashed. Following the crash, the vehicle was left unresponsive. Tesla Service conducted a diagnostic review and isolated the problem to a physical failure of the internal hardware: Assembly - Power Conversion System - 48Amp - 1Phase. The vehicle was performing flawlessly and charging efficiently prior to the software update execution. The...
PCS module did not break due to driver abuse, mechanical wear, environmental damage, or physical aging. It failed strictly because Tesla's proprietary software update process overtaxed, corrupted, or bricked the internal semiconductor boards during a forced rewrite command. A consumer should not be financially penalized for hardware damage caused by a manufacturer's remote software push.
My Tesla was operating with Full Self-Driving (FSD) (Supervised) engaged when it initiated a left turn across the path of an oncoming vehicle traveling in the opposite direction, resulting in a collision. During the incident, FSD was controlling the vehicle's driving behavior and initiated the left turn despite the presence of oncoming traffic. The Tesla collided with the approaching vehicle while executing the turn. I am concerned that the FSD system failed to properly recognize or respond to oncoming traffic,...
failed to determine whether the left turn could be safely completed, or made an unsafe decision to turn across the path of another vehicle. This incident created a significant safety risk for the occupants of both vehicles. I believe the collision may indicate a safety-related problem involving FSD's intersection handling, left-turn decision-making, detection of approaching vehicles, or collision avoidance capabilities. I request that NHTSA review this incident as a potential FSD safety defect and obtain relevant FSD engagement records, vehicle telemetry, camera footage, steering commands, and collision data from Tesla to determine why the vehicle initiated the left turn into oncoming traffic.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data
Owners helping owners
Know before you drive.
Every experience you share - good or bad - shows on that vehicle's page and helps the next owner and buyer. Two minutes, anonymous.
Share your experience