- The problem
- Daimler trucks is recalling 3,773 my 1996 through 2002 thomas built mvp er school buses manufactured from june 8, 1995 through february 16, 2001, equipped with caterpillar 3116 and 3126 engines. Un-fused power cables were tie-wrapped to a wire braid engine fuel return hose. Over time these cables may chafe, wearing through the wire loom and eventually through the cable insulation and fuel line covering in an area not easily detectable during normal maintenance without removing the tie wraps and opening the wire loom. Un-fused and un-switched power cables which wear through and contact the fuel line wire braid may short circuit.
- The risk
- In the event of a short circuit, a vehicle fire can occur.
- The fix
- Thomas built will notify owners and inspect and replace the cables as necessary free of charge. The recall is expected to begin on or about november 28, 2008. Owners may contact thomas built at 1-336-889-4871.
Vehicle safety record
2000 Thomas MVP ER Problems, complaints & recalls
No owner complaints about the 2000 Thomas MVP ER have been filed with NHTSA. It is covered by 12 recalls, the latest in July 2008 for the engine and engine cooling.
NHTSA data checked
DMore problems than a typical MVP ER year, for its age
- Complaints
- 0
- Recalls
- 12
- Crashes
- 0
- Fires
- 0
- Injuries
- 0
- Deaths
- 0
2000 Thomas MVP ER recalls 12
Recall repairs are free. Your dealer fixes them whether or not you bought the car there - check your VIN at nhtsa.gov/recalls to see if yours is done. What to do
- The problem
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (Additional buses have been added to this recall campaign. Please see supplemental report no. 4) The emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
- The risk
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- The fix
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. Owners may contact thomas built at 336-889-4871.
- The problem
- Certain my 2000 through 2003 thomas built hdx and mvp-er school buses manufactured between april 23, 2000, and november 14, 2003. The service air brake pedal, for both non-adjustable and adjustable brake pedals, may contact the front structure on the bus, limiting the maximum brake force available.
- The risk
- Insufficient air brake pressure may cause extended stopping distances without prior warning, possibly resulting in a vehicle crash.
- The fix
- Thomas built will notify owners and repair the affected buses free of charge. The recall began on september 14, 2007. Owners can contact thomas built at 336-889-4871 or contact freightliner at 800-547-0712.
- The problem
- Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
- The risk
- Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
- The fix
- Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.
- The problem
- On certain school or transit buses with passenger seat belts with retractors, the cover halves for the retractable portion of the belt can separate completely and release the seat belt connector. If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury. The seat belt supplier, amsafe, will provide a snap on "over-cover" to owners to prevent the seat belt cover from separating.
- The risk
- If this occurs, one of the load bearing pins in the connector could separate from the connector and render the seat belt unusable. In the event of a crash, the seat occupant would not be properly restrained resulting in an injury.
- The fix
- Dealers will provide a plastic outer cover that snaps over the existing cover on units in the field and will replace broken seat belts free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-841-5924 or amsafe at 574-266-8330.
- The problem
- On certain school and transit buses, the wheel lug nut may not tighten completely.
- The risk
- The wheel could loosen increasing the risk of loss of control of the vehicle.
- The fix
- Dealers will install new wheel studs. Owner notification began february 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.
- The problem
- On certain school buses, misalignment of the fan drive system components can cause premature belt and pulley bearing wear.
- The risk
- If the school bus is disabled by a cooling system failure and is stalled on the side of the road, an increased risk of a crash resulting in injury to a school bus occupant could occur.
- The fix
- Dealers will replace the fan belt, idler pulley, and belt tensioner and the pulley's laser will be aligned. Owner notification began june 10, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- The problem
- Vehicle description: school and transit buses equipped with safety belt assemblies produced by am-safe. On some seat belts, the buckle and connector may unlatch during a collision.
- The risk
- Serious injury or death could occur if the vehicle occupant is not properly restrained.
- The fix
- Am-safe notified thomas built's customers to return their vehicle to an authorized dealer to have the seat belts repaired free of charge. Owner notification began september 21, 2000. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-889-4871.
- The problem
- Vehicle description: certain school buses fail to comply with requirements of fmvss no. 121, "Air brake systems." These vehicles do not comply due to the low air warning system detecting pressure in only one reservoir system and not both as required.
- The risk
- THIS DOES NOT MEET THE STANDARD.
- The fix
- Dealers will correct the low air pressure switch wiring. Owner notification began july 27, 2001. Owner notification is expected to begin owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-881-7219.
- The problem
- Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. A bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. This bracket is located at the top of the height adjuster.
- The risk
- If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- The fix
- Dealers will replace the seat base and add reinforcement to the seat assembly
- The problem
- Vehicle description: school bus chassis and emergency vehicles built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- The risk
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- The fix
- DEALERS WILL REPLACE THE ABS ECU.
- The problem
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- The risk
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- The fix
- DEALERS WILL REPLACE THE ABS ECU.
What owners say
Be the first MVP ER owner to share.
Problems or none - your experience is exactly what the next buyer is looking for. Write it now
No complaints about the 2000 Thomas MVP ER yet
No owner has filed a complaint about this vehicle with NHTSA. If yours has a problem, share it here and report it to NHTSA.
Thomas MVP ER: every year compared
All MVP ER years2000 Thomas MVP ER vs rivals
| Vehicle | Complaints | Recalls | Grade | |
|---|---|---|---|---|
| 2000 Thomas MVP ER | 0 | 12 | D | |
| 2000 Thomas Bus | 3 | 0 | F | Compare |
| 2000 Thomas Saf-T-Liner HD | 1 | 2 | - | Compare |
| 2000 Thomas CL100 | 1 | 1 | - | Compare |
More sales usually means more complaints, so compare similar vehicles of the same year. The grade compares each vehicle with its own model's other years.
Questions about the 2000 Thomas MVP ER
Does the 2000 Thomas MVP ER have any recalls?
Yes - NHTSA lists 12 recalls for the 2000 Thomas MVP ER: engine and engine cooling (July 2008); hinge and attachments (February 2008); service brakes, air (March 2007); fuel system, diesel (April 2005) and more. Recall repairs are free at any authorized dealer. Enter your VIN at nhtsa.gov/recalls to see whether yours has been fixed.
How many complaints has the 2000 Thomas MVP ER had?
None have been filed with NHTSA so far.
Is the 2000 Thomas MVP ER a reliable vehicle?
Its Safety Index is 26 out of 100 (grade D: more problems than a typical Thomas MVP ER year, for its age). The index weighs complaints, crashes, fires, injuries, deaths and recalls against how long the vehicle has been on the road, compared with the same model's other years. It is not a measure of every repair - read the complaints and owner experiences, and have any used vehicle inspected before you buy.
What should I do if my 2000 Thomas MVP ER has a problem?
If it is a safety problem, stop driving it if it is unsafe and contact your dealer. Report it to NHTSA at nhtsa.gov/report-a-safety-problem - enough reports start investigations and recalls - and share your experience here so other owners know what to look for.
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked . Complaints are owners' own reports and are not verified. How we use the data