2022 Ram Promaster Problems, complaints & recalls

Stellantis to recall and my van was a omission. i want to be assured that i have a safe van to drive. would like your help if you can to get this van as part of the recall from manufacture vin#[[redacted]] [[redacted]] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Covert Dodge Ram (Ram dealer, Research Blvd, Austin, TX), which confirmed the failure and identified the electric power steering wiring jumper harness between the EPS gear and the EPS module as the cause. This matches open recall 26V-621 (FCA 92D), which shows on this VIN as 'remedy not yet available.' Because no remedy is available, the dealer is asking me to pay for the repair and seek reimbursement from FCA. The vehicle is not safe to drive until repaired. Failed parts can be made available for inspection on request. Mileage approximately 103,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

replaced out of pocket. The passenger side window actuator broke, had fixed at dealer then it broke a week later, had dealer repair again. The windshield cowl leaks rain water into and onto the motor. There is a recall open now for power steering with no remedy and was told to keep driving it even if we are not compfortable knowing the steering can go out any moment. Brought to dealer and they claim they dont know what to do and didnt offer a rental. The steering has not failed yet every owner we speak with on the road and online has had all the same exact issues. We only have recepts for coolant and roof repairs

corrode. The dealership is telling me that not only is the part not under warranty, but they don't have it and have no idea when they will get this part. I had the exact same issues with another one of my vans last year. it took six months for the repair part to come in. Two vans, one with 20,000 miles and one with 48,000 miles, both the same issues and the same issue getting the correct replacement part.

would need to pay approximately 1,500 for repairs. I was surprised because there was no known leak when I delivered the vehicle. I immediately contacted MOPAR for assistance and asked whether the leak could be related to the recall service or whether the repair should be covered. Unfortunately, MOPAR did not resolve my concern. I declined the 1,500 repair. The dealer told me they could not guarantee there would be no leaks after the recall repair was completed. When I picked up my truck, the dealer did not tell me that the coolant leak was still present or warn me about driving the vehicle. I drove the truck home. After getting home, I opened the hood and discovered a long screwdriver left inside the engine compartment. I am not claiming that the dealer caused the coolant leak. However, I am concerned about the timing of the leak, the recall service, the 1,500 repair demand, the lack of warning at pickup, and the screwdriver left in the engine compartment. I respectfully request that NHTSA investigate whether this coolant leak may be related to Recall 67C, the recall repair, an improper repair, or another safety defect. NOTE: I am now seeing on your website that it appears the Recall 67C repair has not been recorded as completed for my vehicle. I have uploaded a screenshot of the information shown on the website for your reference. Please review this discrepancy as part of my complaint. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

driver and all others on the road was at risk, as the 2022 Promaster 3500 is a heavy vehicle that could become unmanageable without power steering. Problem was confirmed by EAS Tire and Auto in Lafayette, Colorado. The component was returned to Mopar when the new component was ordered. This issue is an additional example/complaint to NHTSA Investigation PE26-002 for intermittent or complete loss of electric power steering, including reports involving water intrusion and corrosion affecting the power steering system. My vehicle exhibits substantially similar symptoms and diagnostic findings. I have a finalized repair invoice, diagnostic report showing DTC C1593-49, and photographs of corrosion/connectors.

rainfall, water entered the intake system and subsequently reached cylinders 2 and 4, causing the engine to hydrolock upon startup. The engine was rendered inoperable at only 29,139 miles. Detailed Description of the Incident The vehicle was parked outside an auto repair facility for a routine battery replacement. It was not driven during this period. Over the course of two heavy rain events, water entered the engine compartment through the failed seam in the two piece cowl. When the repair facility attempted to start the vehicle, the engine immediately hydrolocked. Upon disassembly: •The air intake tract was found full of water. •The intake manifold contained pooled water. •Cylinders 2 and 4 contained water. •The engine suffered internal damage consistent with hydrolock and was declared a total loss. All findings were documented by the mechanic, including photographs and diagnostic notes. Safety Concern This failure represents a serious safety defect. Water intrusion through a structural component should not be able to reach the intake manifold or engine cylinders under any circumstances - especially while the vehicle is stationary. A sudden hydrolock event can cause: •Immediate engine shutdown •Loss of motive power •Loss of power steering and braking assist •Potential loss of control if occurring while driving •Extremely costly engine destruction Inspected by mechanic. Nobody else. No warnings.

this initial occurrence but have yet to hear back. Last night, July 26, 2026, the issue occurred again as I was attempting to back out of my driveway. As I tried to turn the steering wheel it seemed to "fight" me, becoming difficult to rotate and violently jerking the other way against the direction I was attempting to rotate it. I switched from reverse to drive and was able to re-park the van where it was parked prior. My safety was not compromised in any considerable manner as this occurred at low, "driveway" speed. It was just me in the vehicle with no one else around. The problem has not been reproduced by a dealer yet nor has it been inspected by a dealer or service center. The warning lamps for the ESC and EPS came on once the problem began occurring but seemed to turn off after restarting. The problem appears to be currently intermittent in nature but, based on other accounts, the fact that this is occurring is seemingly indicative of a more serious issue in how this vehicle was manufactured. My concern is this happening at highway speeds where my safety and the safety of others will be jeopardized. ***I have a video I can send you but the link below does not allow mp4 files***

bottom floor of the connector housing, causing severe copper oxidation (galvanic corrosion) and visible electrical arcing on a constantly energized 12V male pin inside the EPS gear cylinder. This high-current bottleneck drops voltage under load, causing the internal ECU to cut assist as a safety fail-safe.Critically, this design defect created an immediate, progressive cascading failure dating back to the very first month of ownership. Because this 12V power line remains constantly "hot" while parked, the pooling water established an un-metered short-circuit bridge directly to the frame ground. This forced an aggressive parasitic electrical drain that repeatedly flattened the battery after sitting for short two-week intervals throughout its lifespan, destroying the original factory battery.The dealer's safety protocol requires a complete steering rack replacement. However, because Ram recognized this vulnerability, they completely superseded the part with a redesigned assembly that forces consumers to purchase new, non-faulty tie rod assemblies just to make it compatible, inflating costs to over $6,000. This data directly supports the active NHTSA investigation into 2022-2023 ProMaster steering modules. Furthermore I imagine that since some people may continue to drive the vehicle under this particular condition of "barely being affected" until there is sudden failure on the highway or zero signs prior to catastrophic failure. I STILL OWE $ ON THIS VEHICLE

to me is dangerous and just not right. My Promaster is a Roadtrek van and the service manager at the dealer where I purchased the van says he sees this light on all the time on other Promaster vehicles and just ignores it. I see many posts on Roadtrek and Promaster forums that reference people having the same issue. Ram dealer finally acknowledged the issue but is unable to get any acknowledgement from the manufacturer that they are working on a fix. I've had this issue from day one and have taken it to the dealer several times with no resolution. This is one thread that documents what I have experienced as well: [[redacted]] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

should be able to drive a vehicle with this kind of problem. This recall was issued several months ago, I think from October 2025. This van has a camper made in it by Thor Twist and sold by Camping World in Arkansas. We bought it to travel around the country we retire. What a nightmare. We have a granddaughter who lives with us and goes camping with us most of the time. We also have a handicapped daughter who also travels with us sometimes. She has never been able to walk. What if the van catches on fire while she is with us? My wife and I are in our mid [[redacted]] . We have been losing sleep thinking about this The people we bought it from said it's not their responsibility, same as Thor Twist. They say it's a chassis problem and we need to call Chrysler Corporation. I called the Chrysler Corporation the Dodge dealership near our location. Recall notice states "The remedy for this condition is not currently available. We can't plan any vacation time due to this recall. We now have nightmares about traveling anywhere in this van. We paid over $100,000 for this van and cannot use it. We are requesting that we return the van and get all our money back. We have had nothing but problems with this van and worry about making any trips in it in the future. We have had it in the shop 4 times for recalls and several other times for malfunctioning issues. We were unable to use the van for weeks at a time. Let us return it please. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

steering connector, causing the power steering failure. The owner was informed that the steering rack needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not contacted. The contact was informed of NHTSA Action Number: PE26002 (STEERING, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the investigation. The failure mileage was 68,974.

offered rental reimbursement, but this does not provide a safe or realistic interim solution for a vehicle that functions as both transportation and housing. The manufacturer has acknowledged a fire risk but has provided no interim safety guidance or accommodation for owners who cannot reasonably stop using the vehicle while awaiting a remedy. I am reporting this as a safety concern due to the lack of a remedy and the absence of interim safety guidance for affected owners. Stellantis has issued a stop-sale on affected vehicles, confirming the seriousness of the defect, while existing owners remain without a viable safety alternative.

prevented by the manufacturers.. I also had a Transmission replacement at 30k miles and full Engine replacement at 55k miles. Currently at 80k Miles... This is Unacceptable for a Commercial fleet vehicle.