Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and...
Acceleration & cruise control
Ford Explorer Acceleration problems by year
538 complaints filed with NHTSA about the Ford Explorer's acceleration & cruise control. Unintended acceleration, surging, throttle problems and cruise or adaptive cruise faults.
Acceleration complaints by model year
Acceleration recalls
On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
On certain sport utility vehicles equipped with speed control and 4.0L sohc engines, if the strand cover on the speed control cable becomes flared at the end, the speed control cable may bind when the speed control is activated.
Vehicle description: sport utility vehicles equipped with 4.0L sohc engines and still retain the original throttle body (part numbers 97jf-9e926ab or 97jf-9e926-ac). Some of the original throttle bodies installed allowed a gap between the plate and bore...
Vehicle description: certain 1997-1999 rhd explorer equipped with 4.0L ohv/sohc engines and cruise control built from may 29, 1996 through march 4, 1999; 1998-1999 explorer/mountaineers equipped with 4.0L ohv/sohc or 5.0L engines or 1998-1999 rangers...
Vehicle description: multi-purpose passenger vehicles equipped with 5.0L engines originally sold or currently registered in the states of alaska, idaho, iowa, maine, michigan (upper peninsula only), minnesota, montana, nebraska, new hampshire, new york...
Latest Explorer acceleration complaints
The contact owned a 2025 Ford Explorer. The contact stated that while his wife was making a right turn into a resident carport, the vehicle surged forward and crashed into the house at approximately 10-15 MPH. The brake pedal was depressed during the failure. The contact was following his wife at the time and became aware that the brake pedal was being depressed. The air bags deployed on the driver's and passenger's sides, steering, curtain, and footwell. The driver sustained bruises from the air bag and seat belt....
Read the full complaint
The vehicle was towed. The EMT provided medical attention at the scene. A Police report was filed but the police report number was not available. The manufacturer was contacted by phone and opened a case. The vehicle was inspected and totaled by the insurance company. The failure mileage was approximately 27,954.
The contact owned a 2018 Ford Explorer. The contact stated that while driving at various speeds, a message displayed on several occasions instructing the driver to pull over and shut off the vehicle because the battery would shut off. Upon pulling over and turning off the vehicle, the vehicle failed to restart and required towing on several occasions. The vehicle was towed to the dealer, where a wiring failure was determined. The dealer attempted to repair the vehicle, but the failure persisted. While driving...
Read the full complaint
approximately 25 MPH, the infotainment screen turned blank, and a large wrench warning light illuminated. The vehicle independently accelerated, became uncontrollable, and drifted out of the intended lane. The contact regained partial control as the vehicle continued accelerating toward an embankment. The front driver's side wheel was caught in the gutter of the embankment, causing the driver's side of the vehicle to crash into the embankment. The contact's head struck the driver's side window, which was fractured, allowing branches to enter the cabin. The driver's side curtain air bags deployed for the second and third rows but failed to deploy properly for the front driver's side, causing the contact to hit her head a second time on a sail that had deployed. The contact became pinned between the driver's seat and the driver's side window area, with her hair caught and pulled in the seat belt pretensioner, causing significant pain. EMT personnel cut the contact's hair to free the contact from the vehicle. The contact was assisted from the vehicle, fitted with a neck brace, placed on a stretcher, and transported to the hospital. The contact sustained head and neck injuries, as well as a concussion. Additionally, the contact suffered from pre-existing auto-immune lumbar stenosis L1-L5, osteoarthritis L5-S1 with bone-on-bone contact, and sacroiliac joint disease, and experienced increased pain after missing a scheduled appointment for sacroiliac joint injections due to the crash. A Police report was filed but was not available. The vehicle was towed and deemed a total loss by the insurance company. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown.
I was driving down the road when the warning lights suddenly came on, and the vehicle would not allow me to accelerate. As a result, my vehicle slowed unexpectedly, and another vehicle nearly struck me from behind.
When going around a curve the steering wheel is sticking on the right. I have to tighten my grip on the wheel and manually straighten the wheel. This happened to me several times today on my 50 min trip. This was very frightening to me making me scared the wheel would stick and I have no control of the car while driving. I purchased this car on sat June 27. It just started today July 3. I am planning to take it back to the dealership on Monday.
The transmission malfunctioned on the Interstate. The car started jumping and then would slow way down to about 33 MPH with the RPM's super high and then kick back in and speed up super fast and I would have to brake constantly. I almost hit the car in front of me at one point. A different point in the same trip the car behind me had to slam on it's brakes to stop from hitting me when the car lost power. I got off the Interstate at the very next exit and took back roads home. The transmission has been...
Read the full complaint
inspected by a Ford Dealership and they said it was the transmission going out. At first there were no warning lights and after it started jumping and starting. Then a few days later the engine light and power train warning lights came on.
The Speed Sign Recognition feature misread a "CC" cross road sign as being a 60mph speed limit sign and caused the Predictive Speed Assist feature to change the speed control set pont from 25mph to 60mph while in town and in a school speed zone. The abrupt change in speed control setting caused the vehicle to aggressively accelerate without warning and without driver input. The issue has been reproduced many times with many new vehicles at multiple locations. It is consistent.
Vehicle equipped with operational red and blue emergency lights prohibited by law, facilitates criminal activity such as impersonation of a police officer, civil regulatory laws regarding excess auxiliary lights, etc. Seller has actual knowledge and can be liable under color of law upon a purchase agreement with a buyer. Vehicle has open recalls and unresolved mechanical/electrical maintenance.
Since purchase as a preowned vehicle, we noted this vehicle is equipped with a faulty transmission/tcm software design that is dangerously unpredictable and creates erratic driving conditions. This passenger SUV Is equipped with a 10 speed automatic that (once at operating temperature) the gear shifts and operation become highly unpredictable, often causing severe safety issues navigating in traffic, slowing down to sudden stops, and any acceleration, frequently getting stuck in 1st gear or neutral while attempting...
Read the full complaint
to accelerate on roadways from a stop. The (10r60E) has nearly caused several accidents severe accidents while under normal use as our primary family vehicle. The Ford dealerships I contacted were aware the problem was concurrent on every vehicle equipped with that Transmission and deemed it normal operation. This is highly concerning there hasn't been some sort of safety recall implemented as it is a known flaw that creates very unsafe driving conditions on a vehicle marketed to families.
The specific component or system has not fully failed. However, my vehicle is currently experiencing an intermittent check engine light condition, turning off and on, which was diagnosed at a Retailer producing code P0018 then at the dealership and produced code P0017. The codes relate to the engine control module (ECM) detects that the camshaft on is out of sync with the crankshaft resulting in misaligned engine timing. I have requested that the dealership further review and escalate the diagnosis to determine...
Read the full complaint
whether the issue aligns with any known concerns, Technical Service Bulletins, or manufacturer-supported programs. The vehicle and any related components are available for inspection upon request. At this time, the vehicle experiences reduced engine performance, including stalling, and inability to accelerator as needed, which pose a safety risk while driving, particularly in traffic or at highway speeds. The vehicle has been inspected and confirmed by the dealership. I have also contacted the manufacturer, who advised me to work directly with the dealership to have the issue reviewed and potentially escalated. I have since requested that they further evaluate the condition and determine whether it corresponds to any known issues or manufacturer-supported repair programs. At this time, the vehicle has not been inspected by police, insurance representatives, or other third parties. This check engine light and fluctuating RPM directly impacting the vehicles acceleration was the primary indicator of the issue. The manufacturer previously issued two Customer Satisfaction Program notices to address this issue for other model year vehicles. I have attached both notices to this complaint. This demonstrates a manufacturer defect which is a safety hazard for drivers.
The contact owns a 2020 Ford Explorer. The contact stated that while driving 75 MPH with cruise control activated, the vehicle unintendedly decelerated while the accelerator pedal was depressed. No warning light was illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired because the VIN was not under recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 26,000.
On March 2nd 2026, while operating my 2025 Ford Explorer ST at highway speeds of approximately 78 MPH, the vehicle experienced a sudden, uncommanded shift from Drive into Neutral. This resulted in an immediate and total loss of motive power in live traffic, creating a life-threatening safety hazard as I was unable to maintain speed or accelerate away from surrounding vehicles. Notably, the dashboard displayed no warning lights, wrench icons, or error messages during or after the event. I was forced to coast across...
Read the full complaint
lanes of traffic to reach the shoulder. This is the 7th significant warranty-related issue this vehicle has experienced since purchase in May 2025, representing a substantial impairment to the vehicle's safety, use, and market value under Wisconsin Lemon Law.
I am filing a safety defect complaint regarding my 2017 ford explorer. The B pillar has broke in half a couple of years ago and nearly struck a vehicle behind me and if the remaining trim piece detaches, it could become a serious risk of collision, injury or property damage. it states NHTSA works to prevent unsafe traveling which is why I'm writing this. I have contacted Ford customer service and dealerships multiple times with no luck of anything. I have had to continuously tape the area to door which is not...
Read the full complaint
ordeal nor a forever fix. The b pillar is held on by wires that are slowly breaking. The wires lead to a hole that is inside my door. the opening exposes from the outside, meaning if it rains or snows, it is getting inside the hole, into my car door. If the recall piece ever came in, my door has already experienced neglect and issues. I'm concerned this will lead to corrosion, electrical complications and additional mechanical failures. Also, if it is not taped up correctly, air blows directly into the car door, into the cabin while driving onto my feet causing extreme cold exposure and physical harm and making it hard to operate the vehicle. It's very painful and also not ideal, especially when I also have a full time job and 3 kids to worry about. I currently owe 12k still on the vehicle and want to replace it with a safer vehicle. I should not have to be miserable every single day and put me and my kids in danger and also let my vehicle deteriorate while i wait for this recall piece on top of having to pay the remaining balance of this vehicle. I respectfully request that nhtsa review this complaint and investigate before anymore physical, emotional, financially harm is done.
Vehicle did not want to shift above 35 mph. When letting off gas - harsh downshift (with no break lights) at 25mph. Diagnosed transmission problem - repaired- Ford dealership rebuilt transmission. No warnings or messages prior to failure.
- I have experienced a sudden loss of engine power and speed on 5 occasions. Very scary and dangerous to completely lose power on the highway with cars behind you. Had to pull off onto the shoulder(s) in dangerous conditions, with two young kids in the backseat. Hazards, turn off the car, restart the car, etc. - When the power loss happens, the vehicle's dashboard lights turn on, including the engine and wrench icons along with the words "See Manual." - Based on my research, I believe it may be due to a...
Read the full complaint
defective throttle body and/or software, related to the "terrain management system." - Problem was not reproduced or confirmed by a dealer or independent service center - No inspections by the manufacturer, police, insurance representatives or others - No warning message is provided prior to the failure, which is another issue
See Attached Repair Order
Source: U.S. National Highway Traffic Safety Administration (NHTSA) complaints and recalls, checked daily. Complaints are owners' own reports and are not verified. How we use the data